Always use the correct tools for the job

Slides:



Advertisements
Similar presentations
Always start a vehicle correctly
Advertisements

Beware of hazards around you
PDO Second Alert What happened:
Always comply with Defensive driving techniques
Always use mechanical handling aids when carrying out a heavy lift
Ensure a safety briefing is given where appropriate
Always use mechanical handling aids when carrying out a heavy lift
Always stay alert while driving, and observe other drivers behaviour
Always use 3 points of contact when using ladders
Always ensure the right tools are used for the task
PDO Second Alert Date: Incident : LTI What happened?
Comply with Safe Operating Procedures
PDO Second Alert Valves open Valve closed Valves open Valve open
Never place yourself in line of fire
Ensure all safety covers and guards are secured and in place
Always think to use hands off technique.
PDO Second Alert Stay out of the line of fire What happened:
Drive with appropriate speed to road conditions
Identify Pinch Points and keep your Hands & Fingers away
Use right tools for the job and use them correctly
Do not work at height without fall protection
PDO Second Alert Date: Incident type: LTI What happened?
Ensure to use the right tools and equipment for the activity
Avoid taking shortcuts
Follow Management of Change for an activity which is not in permit
PDO Second Alert Date: Incident: LTI What happened?
Keep away form ‘line of fire’
Keep away from “Line of Fire”
Always use the right equipment for the task !!!!
Follow the rules to save a life
Ensure OHL Clearance required for your lifting activity
PDO Second Alert Date: Incident Type: LTI What happened?
No hands on elevator while delivering pipe
Never put your Hands in line of fire
LTI: Finger Crush Injury Hands off suspend loads “Use Tagline”
Always stay out of the line of fire
Ensure cat line are under tension before removing elevator bolts
PDO Second Alert Always follow the PTW procedures
Unsecured pup joint falling
PDO Second Alert Date: Incident: LTI What happened?
PDO Second Alert Use Hands Free Lifting Aids What happened?
Always report Near Misses
PDO Second Alert Date: Incident title: HiPo Asset Damage
Always use secondary retention
Keep your hands in a safe position
Never place yourself in “line of fire”
Always keep your hands away from crush points (Line of Fire)
Always use your hands to set the slips
Always assess the risks, Stop and think.
PDO Incident First Alert - STST
PDO Second Alert What happened? Your learning from this incident..
When operating the Tongs under tension, make sure all crew keep clear
PDO Second Alert Date: Incident title: HiPo What happened?
Your health is your responsibility
Always ensure “no go” zone are in place
Check equipment prior to start the job
PDO Second Alert What happened? Your learning from this incident..
Be aware of potential pinch points
Use only certified lifting equipment in good condition
Always intervene an unsafe act
Always keep your hands and fingers away from the Line of Fire
Always keep your equipment maintained
Stay away from line of fire
Use a tool and protect your hands
SHORTCUT ROAD DRIVING IS DANGEROUS
Keep away from “Line of Fire”
Keep away from the line of fire
Beware of raised edges of walk ways.
Keep hands out of the line of fire
Use hands-off where possible
Presentation transcript:

Always use the correct tools for the job PDO Second Alert Date: 22.07.2017 Incident: LTI What happened? A mechanical crew was engaged in removal of bolts from a flange as part of commissioning and de-spading activities. Whilst one of the crew members was hammering a spanner to remove bolts, a small splinter from the hammer cut through his cotton glove and hit his right index finger. This caused a minor superficial scratch injury on the finger. First Aid was given at site clinic and later he was diagnosed with partial tear on his right index finger extensor tendon which required a surgical repair. Your learning from this incident.. Keep away from “line of fire” of tools and equipment Always carry out pre use inspection and ensure regular maintenance of hand tools Ensure all staff always use appropriate PPE for the job Report all incidents immediately to comply with procedures Always use the correct tools for the job

Management self audit Date: 22.07.2017 Incident: LTI As a learning from this incident and ensure continual improvement all contract managers must review their HSE HEMP against the questions asked below Confirm the following: Do you ensure that employees are aware of the importance of immediately reporting of incidents? Do you ensure that your team members are aware of the dangers of “Line of Fire”? Do you ensure pre-use inspection and maintenance of hand tools? Do you ensure that your employees are using right PPEs for the job? Do you encourage your employees to intervene when they see an unsafe act or condition? Do you ensure your work teams follow best practice when performing their tasks to ensure safety? Make a list of closed questions (only ‘yes’ or ‘no’ as an answer) to ask other contractors if they have the same issues based on the management or HSE-MS failings or shortfalls identified in the investigation. Pretend you have to audit other companies to see if they could have the same issues.