Ceramic Filter for Brine Filtration

Slides:



Advertisements
Similar presentations
St. Eustatius drinking water production
Advertisements

1 Hydroflow Filtration Systems F I L T R A T I O N S Y S T E M S HYDROFLOW SURFACE FILTRATION Versus DEPTH FILTRATION In Metalworking Fluids  SURFACE.
Removal of Cu(II) ions from aqueous solution effluent using Melamine-Formaldehyde-DTPA resin in a fixed-bed up-flow column By Ahmad Baraka Supervisors.
Challenge the future Delft University of Technology Superviser: A/Prof. Bas Heijman Promotor: Prof. Luuk Rietveld Ran Shang.
CE 370 Filtration.
The AFC Process What Is AFC? Key Operations are  Balancing of incoming waste streams  Thermophilic activated sludge (AFC) to oxidise the organic.
Membrane distillation Technology & Applications
Figure 1. Particle size distribution of a bentonite suspension after four settlings.
• Electrodialysis (ED). • Liquid membranes. • Pervaporation.
Super-M Hollow Fiber membranes for Purification, Separation & Concentration About Super-M PHILOSEP Super-M is UF/MF membrane module optimized to separation,
Treatment of wastewater by combination of ozonization and membrane separation Zsuzsanna László, Cecilia Hodúr.
Why Use Ozone  To improve water quality (disinfection)  To improve swimmer comfort  To reduce maintenance costs  To reduce chemical costs  To improve.
Technical Manager, Hydropath Holdings Ltd.
I-MBR Side-stream, in vitro MBR system for Water Treatment About i-MBR Modules PHILOSEP i-MBR is in vitro, cased and decompression type membrane modules.
Configuration.Modules.Transport.Fouling
Membrane Processes •A membrane is a selective barrier that permits the separation of certain species in a fluid by combination of sieving and diffusion.
Hot Surface Igniters. PRESENTED BY: Joe Barker Brent Blume Sam Alauddin.
Sanitary Disposable Pumps fill a real need in the marketplace Sanitary Disposable Pump Entire pump is disposable - not just components Cost effective.
MUD SYSTEMS, MUD DATA & HYDRAULICS A.Fresh Water Muds B.Inhibited Muds C.Water Base Emulsion D.Oil Base & Synthetic Muds I- MUD SYSTEMS.
Ceramics for Environment
Drinking Water Treatment 1 Lyon, Pollutec 2008 Fine Bubbles, Big Effect Deacidification of Drinking Water Dr. Andreas Dülberg.
Polymers for heavy engineering applications. PEEK Chemical Resistance Since PEEK™ polymer is semi-crystalline, it is insoluble in all common solvents.
Combined Ozonation-Nanofiltration for Drinking Water Treatment B. S
Reverse Osmosis Lec. 9 Dr. Ola Abdelwahab.
Waupun Utilities Water Treatment Facility. Treatment Processes Source Water Pretreatment System Reverse Osmosis System Post Treatment System Distribution.
How to obtain fresh water Section - E6.3 Chemistry 12 – SL Isabelle R.
Mechanical Design Of Process Equipment.
Reverse Osmosis Ultrafiltration Microfiltration
Alternative Separations
DESALINATION. MEANING THE TABLE GIVEN BELOW IS THE LISTS OF THE CONCENTRATIONS OF SEVEN SUBSTANCES THAT TOGETHER COMPRISE MORE THAN 99 PERCENT OF THE.
Cross-border network for knowledge transfer and innovative development in wastewater treatment WATERFRIEND HUSRB/1203/221/196 1st HUSRB Students Meeting.
High Rate Thermophilic Anaerobic Membrane Bioreactor for Wastewater Treatment by Kaushalya C. Wijekoon Master Student (st107821) EEM/SERD Wastewater Ξ.
OPTIMAL PERIODIC OPERATION OF REVERSE OSMOSIS DESALINATION UNITS A. Ajbar, K. AlHumaizi, E. Ali Chemical Engineering Dept. King Saud University Saudi Arabia.
Anti – Odour & VOCs Environmental Protection with The Bio-Trickling Filter Technology Daega Powder Systems CO., LTD CHEON-AN.
Considerations for Brackish Groundwater Use as a Water Supply for Small Water Systems and Municipalities Eddie C. Livingston, MSCE, P.E. Livingston Associates,
Waste Treatment, Physical
PMI UF/MF Modules and Systems for Laboratories About PMI PHILOSEP PMI System is designed to execute various experiments of MF/UF membranes and modules.
Matter: Chapter 2 Lesson 3: What are mixtures?. A mixture is a combination of two or more substances. Substances in a mixture can be separated. This means.
Chapter 2 Exercise Thermistor  Also called thermal resistor as the resistance varies as a function of temperature.  Manufactured in the form of beads,
Membrane Processes •A membrane is a selective barrier that permits the separation of certain species in a fluid by combination of sieving and diffusion.
Structure of ceramics Nur Asikin Binti Mohd Nazri Nor Syalmira Binti Amir Nur Afifah Binti Sarkhan Nur Afifah Binti Mohd Rafi
Food processing and preservation. Dr.Mohammad Sabbah. By; Watan Abu Obaid.
Prepared by : Nishant .A. Raval
Distribution System If microorganism colonize a storage vessel, the latter then acts as a microbial reservoir and contaminates all water passing through.
Chapter 6 Reverse Osmosis and Nanofiltration
CENOBEAD TM (CZY & CZC : Stabilized Zirconia Bead) Page: 1/20 YOUNG’S CORPORATION
Status of Hydrogen Separation Membrane Development* U. (Balu) Balachandran, T. H. Lee, L. Chen, and S. E. Dorris Energy Systems Division *Work supported.
CERAMICS. Introduction ~ keramikos - burnt stuff in Greek. ~ Ceramics are inorganic and non-metallic materials that are commonly electrical and thermal.
Zeosorb - The Clean Solution. AMAZING REVOLUTION!! LATEST STATE OF THE ART 3 IN 1 SOLUTIONS Zeosorb FOR YOUR WATER FILTERATION UNITS.
Lecture3_water purification, ChemEng, KKU, M.Thabuot MEMBRANE: Microfiltration Simple screening mechanism Pore size 0.01 μm - 10 μm  P  0.01 to 0.5 MPa.
FERROUS AND NON FERROUS ALLOYS
Morten Lykkegaard Christensen Department of Chemistry and BioScience
Chevron Project: Water Treatment
Muthukumaragurubaran.V
Boiler System Make-up Water Primary Secondary Pretreatment
FERROUS AND NON FERROUS ALLOYS
WATER QUALITY (Chapter 22)
Pharmaceutics-I Lecture No.01
Welcome to the Amrit Filtration Equipments
INTRODUCTION  A membrane is a thin semi-permeable barrier which can be used for the following types of separation: 1. Particle-liquid separation 2. Particle-solute.
PTFE Membrane Market Research Report - Forecast to 2023 Industry Survey, Growth, Competitive Landscape and Forecasts to 2023 PREPARED BY Market Research.
© 2017 Global Market Insights, Inc. USA. All Rights Reserved Ceramic Membrane Market Size, Industry Analysis Report, Regional Outlook(U.S.,
Ceramic introduction.
Natural Ceramic Membrane Filter for Water Purification
JAY POLY TECH INDUSTRIES
Water and its treatment (3)
Irene Caltran Luuk Rietveld Ran Shang Bas Heijman
Example: Separation One method of producing drinkable water is to force seawater through a membrane that does not allow the salt to pass through. A large.
How Reverse Osmosis Water Purification Systems Work
PTFE Membrane Market Research Report - Forecast to 2023 Industry Survey, Growth, Competitive Landscape and Forecasts to 2023 PREPARED BY Market Research.
Presentation transcript:

Ceramic Filter for Brine Filtration Bluestar(Beijing) Chemical Machinery Co., Ltd

Brine Filtration Process Salty Cake (CaCO3 &Mg(OH)2

Brine Filtration Process

Acid/alkaline/oxidation chemicals resistance. Solvent stability. Ceramic membrane Filter - Element> Advantages Acid/alkaline/oxidation chemicals resistance. Solvent stability. High thermal stability and steam disinfected. Wear ability and excellent strength. Stable over a wide pH range. Narrow pore size distribution. Easy to be cleaned and regenerated.

Ceramic membrane Filter – Element’s Material/Structure> Advantages 支撑层 过渡层 分离层 ≥99%α-Al2O3 ≥99.5%ZrO2

Ceramic membrane Filter – Element’s Filtration Description > Advantages Time Flow filtrate feed

Filtered/Purified Brine Ceramic membrane Filter> Assembly Feed Brine Element Filtered/Purified Brine Assembly Concentrated Brine to Circulation-Pump

Ceramic membrane Filter> Assembly

Feed Brine Concentrated Brine Filtered Brine Filtered Brine Ceramic membrane Filter> Assembly Concentrated Brine Filtered Brine Filtered Brine Feed Brine

Ceramic membrane Filter’s Characteristics Ceramic membrane> Industry Application> Ceramic membrane Filter’s Characteristics Support and transition layer: purity≥99% α-Al2O3 Separation layer: purity≥99.5% ZrO2 Chemically stable, no stripping, no silicon. Pore size：50nm Membrane flux：600L/m2.h Operation pressure：0.25-0.4MPa Working life:3years

Ceramic membrane Filter> Industry Application> Refined brine quality Ceramic membrane pore size ≤ 50nm (mean 40nm) Filtered brine SS ≤ 0.5ppm Long-term stability Without fluctuation

Salt mud

End April 2018

Feedback: Privacy Policy Feedback
Do Not Sell My Personal Information
About project: SlidePlayer Terms of Service

© 2025 SlidePlayer.com. Inc. All rights reserved.