Safety Critical Devices can Save the Lives & Protect Asset

Slides:



Advertisements
Similar presentations
Always start a vehicle correctly
Advertisements

Always use mechanical handling aids when carrying out a heavy lift
PDO Second Alert What happened? Your learning from this incident..
Always stay alert while driving, and observe other drivers behaviour
Always use 3 points of contact when using ladders
Always ensure the right tools are used for the task
PDO Second Alert Date: Incident : LTI What happened?
Comply with Safe Operating Procedures
Never place yourself in line of fire
Maintain 3 point contact when you climb Ladder
PDO Second Alert Date: Incident title: Fall from Height
Drive with appropriate speed to road conditions
Identify Pinch Points and keep your Hands & Fingers away
Use right tools for the job and use them correctly
Do not work at height without fall protection
Always ensure a stable position when working at height!
Always wear fall protection equipment when working at height
Ensure to use the right tools and equipment for the activity
Ensure a working platform is adjusted and used
Follow Management of Change for an activity which is not in permit
Always Drive to road conditions
PDO Second Alert What happened?
PDO Second Alert What happened? Your learning from this incident..
Always use the right equipment for the task !!!!
Always follow Night driving rules
Ensure 3 point contact maintained whilst using ladder
Ensure OHL Clearance required for your lifting activity
No hands on elevator while delivering pipe
PDO Second Alert What happened? Your learning from this incident..
Never put your Hands in line of fire
PDO Second Alert What happened? Your learning from this incident..
PDO Second Alert Date: Incident title: Fatality What happened?
Beware of Fall hazards while working at edge of trailer
Adequate tethered tools
If in doubt – stop the job
Always ensure straight lifting
Unsecured pup joint falling
Crane operating with boom lowered and under Supervision
Always report Near Misses
PDO Second Alert Date: Incident title: HiPo Asset Damage
Always use secondary retention
Never place yourself in “line of fire”
Always keep your hands away from crush points (Line of Fire)
Always use your hands to set the slips
Ensure that all Rig moves are carried out by competent personnel
Always stay away from line of fire
PDO Second Alert What happened? Your learning from this incident..
When operating the Tongs under tension, make sure all crew keep clear
PDO Second Alert Date: Incident title: HiPo What happened?
Always ensure “no go” zone are in place
Check equipment prior to start the job
PDO Second Alert Photo explaining what was done wrong
Seek assistance of Banksman while reversing the vehicle
Use only certified lifting equipment in good condition
Safe distance from the edge Maintain a safe distance while driving
PLAN AND DOCUMENT CHANGES TO THE OPERATION
Always keep your hands and fingers away from the Line of Fire
Always keep your equipment maintained
PDO Second Alert What happened? Your learning from this incident..
Check Level Setup prior Lifting & Lowering Operation
Always use fit for purpose lifting accessories
Always adhere to Red/No Go zones
Always drive to the road conditions!
Keep away from “Line of Fire”
Vehicles to Keep Safe Distance at all times
Always position the crane boom correctly before slinging the casing
Confidential - Not to be shared outside of PDO/PDO contractors
Keep away from the line of fire
Beware of raised edges of walk ways.
Use hands-off where possible
Presentation transcript:

Safety Critical Devices can Save the Lives & Protect Asset PDO Second Alert Date:13.08.2017 Incident title: HiPo What happened? On 13th August 2017 at 11:45 hours inside a workshop workshop, while lifting a 3" stainless steel pipe with an Escort Hydra crane, the wire rope which was leading to 2.4 Ton Capacity Hook (weighing 400 Kg) snapped off and the Hook fell with the load to the ground. Due to the impact of the fall, two pipes (3" & 2“) got dent and damaged. Your learning from this incident.. Ensure to use certified and maintained lifting equipment. Ensure deployment of competent personnel. Exercise empowerment to STOP Unsafe Act/Unsafe Condition Always ensure a Lift Plan is in place. Safety Critical Devices can Save the Lives & Protect Asset

Management self audit Date:13.08.2017 Incident title: HIPO As a learning from this incident and to ensure continual improvement all contract managers must review their HSE HEMP against the questions asked below: Confirm the following: Do all your Lifting Equipment meet PDO & International Standards? Do you have Safety Critical Device such as Limit Switch on all Lifting Equipment? Do you have maintenance record of the Lifting Equipment? Do you have competent Operator to operate the Lifting Equipment? 5. Do you assure that daily inspection of Lifting Equipment is carried out? 6. Do you assess all Sub Contractors against 10 Point Checklist? Make a list of closed questions (only ‘yes’ or ‘no’ as an answer) to ask other contractors if they have the same issues based on the management or HSE-MS failings or shortfalls identified in the investigation. Pretend you have to audit other companies to see if they could have the same issues.