OBJECTIVES After studying Chapter 2, the reader should be able to:

Slides:



Advertisements
Similar presentations
Safety Training Presentation
Advertisements

UMES Presented by Environmental Health and Safety Preston Cottman (410) Hazardous Material Spill Response Training.
Reading a Material Safety Data Sheet v An MSDS is written information about the chemicals you are exposed to in shop/work v Every chemical in a shop must.
Proper Automotive Waste Management - Liquid Wastes By Christine Flowers and Raleigh Ross Sponsored by the California Integrated Waste Management Board.
SUNY INSTITUTE OF TECHNOLOGY AT UTICA/ROME Environmental Health and Safety RIGHT-TO-KNOW HAZARD COMMUNICATION REFRESHER TRAINING FOR FACULTY & OFFICE STAFF.
SUNY INSTITUTE OF TECHNOLOGY AT UTICA/ROME Environmental Health and Safety RIGHT-TO-KNOW HAZARD COMMUNICATION REFRESHER TRAINING FOR FACULTY & OFFICE STAFF.
CHAPTER 2 ENVIRONMENTAL AND HAZARDOUS MATERIALS
Safety Training Presentation
Automotive Fuel and Emissions Control Systems, 2/e By James D. Halderman and Jim Linder © 2009 Pearson Higher Education, Inc. Pearson Prentice Hall -
Automotive Engines: Theory and Servicing, 6/e By James D Halderman © 2009 Pearson Education, Inc. Pearson Prentice Hall - Upper Saddle River, NJ
Automatic Transmissions and Transaxles, Fourth Edition By Tom Birch and Chuck Rockwood © 2010 Pearson Higher Education, Inc. Pearson Prentice Hall - Upper.
HAZMAT CONTROL & MANAGEMENT PROGRAM. REFERENCES l 29 CFR l 29 CFR l MCO F, Chapter 18 l Local Base Order HAZCOM.
OBJECTIVES After studying Chapter 2, the reader should be able to:
Introduction to Workshop Safety This presentation will explore: Safety Clothing Workshop Safety Hazards Safety Data Sheets and Labels Storage and Spills.
Campus Safety Training
BLR’s Safety Training Presentations
MSDS Material Safety Data Sheet
Manual Drivetrains and Axles CHAPTER Manual Drivetrains and Axles, 7e James D. Halderman | Tom Birch SEVENTH EDITION Copyright © 2015 by Pearson Education,
Safety Meeting MSDS Sheets EDM Services, Inc, August 31, 2010.
Shop Safety and Operations
BASIC AUTO HAZARDOUS REGULATIONS. WASTE STREAMS RIGHT TO KNOW LAW n Hazard Communication Act of 1983 n Places some responsibility on Employer n Places.
Module 1 : Lesson 1: Working safety in the shop
Hazard Communication Healthcare Workers. © Business & Legal Reports, Inc Session Objectives You will be able to: Understand chemical hazards Interpret.
Safe Chemical Handling
Automotive Service Technology
Safety Training Presentations
Automotive Electricity and Electronics, 2/e By James D Halderman © 2009 Pearson Education, Inc. Pearson Prentice Hall - Upper Saddle River, NJ OBJECTIVES.
Control of Substances Hazardous to Health
Diagnosis and Troubleshooting of Automotive Electrical, Electronic, and Computer Systems, Fifth Edition By James D. Halderman © 2010 Pearson Higher Education,
© 2011 Pearson Education, Inc. All Rights Reserved Automotive Technology, Fifth Edition James Halderman ENVIRONMENTAL AND HAZARDOUS MATERIALS 7.
1 Hazard Communication 29 CFR Introduction l What is Hazard Communication? l Why are we doing it? l What do we have to do?
Always Learning. CHAPTER 2 Environmental and Hazardous Materials.
Automotive Heating and Air Conditioning CHAPTER Automotive Heating and Air Conditioning, 7e James D. Halderman | Tom Birch SEVENTH EDITION Copyright ©
BLR’s Safety Training Presentations
Hazard Communication 29 CFR Close Encounters with Chemicals We encounter chemicals almost every day –Filling your vehicle with gasoline –Cleaning.
Hazard Communication OSHA Standards Material Safety Data Sheets.
Section 3.0 – The Spread of Harmful Substances. Potentially harmful substances are spread and concentrated in the environment in various ways.
WHMIS W H M I S Established October 31, 1988.
Copyright © Business & Legal Reports, Inc. BLR’s Safety Training Presentations Hazard Communication 29 CFR
Environmental and Hazardous Materials 07 Introduction to Automotive Service James Halderman Darrell Deeter © 2013 Pearson Higher Education, Inc. Pearson.
Workplace Hazardous Materials Information System (WHMIS) Hazardous Household Product Symbols (HHPS) There are two systems of hazardous materials labeling.
Copyright  Progressive Business Publications Handling Hazardous Wastes.
Automatic Transmissions and Transaxles CHAPTER Automatic Transmissions and Transaxles, 6e James D. Halderman | Tom Birch SIXTH EDITION Copyright © 2015.
3D LEISURE - Health & Safety Refresher Training Manual.
Bellringer. Types of Hazardous Waste Hazardous wastes are wastes that are a risk to the health of humans or other living organisms. – They include: solids,
Reference: Diversified Health Occupations. Required by many health care facilities To be worn when lifting or moving Effectiveness is controversial, reminds.
Copyright  Business & Legal Reports, Inc. BLR’s Safety Training Presentations Hazard Communication 29 CFR
HAZARD COMMUNICATION. HAZCOM YOU have the Right and Need to know: What hazardous chemicals you work with, Associated hazards, and How to protect yourself.
Cleaning Chemicals PPE Administration Engineering Substitution
These materials have been developed based on applicable federal laws and regulations in place at the time the materials were created. The program is being.
Lesson 5 Workplace Hazardous Material Information System (WHIMIS) and
Automotive Engines Theory and Servicing
Bellwork List 3 dangerous chemicals that you have at home and what you would do if a family member accidentally ingested them.
Bellwork List 3 chemicals that you have at home? What would you do if a younger relative ingested them?
OBJECTIVES Identify hazardous waste materials in accordance with state and federal regulations and follow safety precautions while handling and disposing.
Workplace Hazardous Materials Information System
St. Lawrence-Lewis BOCES “Right to Know” Training
FIGURE 2-1 Material safety data sheets (MSDSs) should be readily available for use by anyone in the area who may come into contact with hazardous materials.
HAZARD COMMUNICATION (HAZCOM)
Unit 1 – Chemistry WHIMIS – MSDS
Reference: Diversified Health Occupations
1 Safety in the Small Gas Engine Shop. 1 Safety in the Small Gas Engine Shop.
Corrosives.
FIGURE 2-1 Material Safety Data Sheets (MSDS) should be readily available for use by anyone in the area who may come into contact with hazardous materials.
FIGURE 2-1 Material Safety Data Sheets (MSDSs) should be readily available for use by anyone in the area who may come into contact with hazardous materials.
Lesson 5 Workplace Hazardous Material Information System (WHIMIS) and
Automotive Engines Theory and Servicing
Automotive Technology Principles, Diagnosis, and Service
In working Places. We use many chemicals… We want you to know how to use them safely You will learn about… The Hazards of Chemicals The Hazards of Chemicals.
Presentation transcript:

OBJECTIVES After studying Chapter 2, the reader should be able to: Define the Occupational Safety and Health Act. Explain the term material safety data sheet (MSDS). Identify hazardous waste materials in accordance with state and federal regulations. Describe the steps required to safely handle and store automotive chemicals and waste. Follow proper safety precautions while handling hazardous waste materials. Understand the ASE requirements for all service technicians in order to adhere to environmentally appropriate actions and behavior.

INTRODUCTION The safe handling of hazardous waste materials is extremely important in the automotive shop. The improper handling of hazardous material affects everyone, not just those in the shop. Shop personnel are required by right-to-know laws to be informed of their rights and responsibilities regarding hazardous waste disposal. Shop personnel must also be familiar with hazardous materials in the automotive shop and the proper disposal methods for these materials according to state and federal regulations.

OCCUPATIONAL SAFETY AND HEALTH ACT The U.S. Congress passed the Occupational Safety and Health Act in 1970. The purpose of this legislation is to assist and encourage the citizens of the United States in their efforts to assure safe and healthful working conditions. Health Care Rights

HAZARDOUS WASTE Reactive Corrosive Toxic Ignitable Radioactive

RESOURCE CONSERVATION AND RECOVERY ACT (RCRA) Federal and state laws control the disposal of hazardous waste materials. Every shop employee must be familiar with these laws. Hazardous waste disposal laws include the Resource Conservation and Recovery Act (RCRA), which states that hazardous material users are responsible for hazardous materials from the time they become a waste until the proper waste disposal is completed.

CLEAN AIR ACT Air-conditioning (A/C) systems and refrigerant are regulated by the Clean Air Act, Title VI, Section 609. Technician certification and service equipment is also regulated. Any technician working on automotive A/C systems must be certified. A/C refrigerants must not be released or vented into the atmosphere, and used refrigerants must be recovered.

MATERIAL SAFETY DATA SHEETS (MSDSS) All hazardous materials must be properly labeled, and information about each hazardous material must be posted on material safety data sheets (MSDSs), available from the manufacturer. FIGURE 2-1 Material safety data sheets (MSDSs) should be readily available for use by anyone in the area who may come into contact with hazardous materials.

ASBESTOS EXPOSURE HAZARD Asbestos exposure can cause scar tissue to form in the lungs. This condition, called asbestosis, causes gradually increasing shortness of breath and permanent scarring of the lungs. OSHA Asbestos Standards EPA Asbestos Regulations Asbestos-Handling Guidelines HEPA Vacuum Liquid/Solvent Brake Cleaners Disposal of Brake Dust and Brake Shoes

ASBESTOS EXPOSURE HAZARD FIGURE 2-2 Brakes should be washed with liquid to help keep brake dust from becoming airborne.

PROPER DISPOSAL Always follow current federal and local laws considering disposal of all waste. Used Brake Fluid Used Oil Origin Use Contaminants Disposal of Used Oil Used Oil Storage

HAND SAFETY FIGURE 2-3 Protective gloves should be worn whenever working around grease or oil to help prevent possible skin problems. They help keep your hands clean, too!

PROPER DISPOSAL Solvents Coolant Disposal Lead–Acid Battery Waste Sources of Chemical Poisoning Effects of Chemical Poisoning Chemical Precautions Status of Solvents as Hazardous and Regulatory Status Used Solvents Coolant Disposal Lead–Acid Battery Waste Status of Batteries as Hazardous and Regulatory Status Battery Handling and Storage.

PROPER DISPOSAL FIGURE 2-5 All solvents and other hazardous waste should be disposed of properly. FIGURE 2-4 Typical fireproof storage cabinet for flammable materials.

PROPER DISPOSAL FIGURE 2-6 Used antifreeze coolant should be kept separate and stored in a leak-proof container until it can be recycled or disposed of according to federal, state, and local laws. Note that the storage barrel is placed inside another container to catch any coolant that may spill out of the inside barrel.

PROPER DISPOSAL Fuel Safety and Storage Air-Bag Handling Used Tire Disposal Air-Conditioning Refrigerant Oil Disposal

PROPER DISPOSAL FIGURE 2-7 This portable gasoline supply is a sealed steel container that is painted red.

PROPER DISPOSAL FIGURE 2-8 Used refrigerant oil should be stored in a clearly labeled, secure container.

SUMMARY OSHA enforces workplace health and safety. Hazardous waste includes reactive, corrosive, ignitable, and radioactive substances that are identified for disposal. MSDSs provide information about potentially hazardous materials. Asbestos is a hazardous material that must be handled and disposed of properly as required by federal and local laws and regulations. Some chemicals and components used in motor vehicle service also must be disposed of properly.

REVIEW QUESTIONS OSHA is short for _________ _________ _________ and _________. Hazardous waste materials are _________ or _________ that the shop no longer needs and that pose a danger. EPA is short for _________ _________ _________. A _________ material can burn skin or dissolve metal. MSDS is short for _________ _________ _________ _________. An MSDS contains information about a _________ _________. _________ _________ or _________ _________ might contain asbestos.

REVIEW QUESTIONS Asbestos exposure can cause _________. Used engine oil should be _________ so it can be used over and over. Automotive solvents that contain _________ _________ solvents can cause health and environmental problems. Cleaning solvents can strip _________ _________ from the skin. Some cleaning solvents have the ability to enter your _________ _________. Technicians should wear protective _________and _________ protection. Antifreeze can cause death if _________. _________ is a very explosive liquid.

CHAPTER QUIZ Student A says the Occupational Safety and Health Act was passed in 1970 to protect workers. Student B says that the Environmental Protection Agency publishes a list of hazardous materials. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ Student A says the Occupational Safety and Health Act was passed in 1970 to protect workers. Student B says that the Environmental Protection Agency publishes a list of hazardous materials. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 2. Hazardous materials include all of the following except _________. engine oil Asbestos Water brake cleaner

CHAPTER QUIZ 2. Hazardous materials include all of the following except _________. engine oil Asbestos Water brake cleaner

CHAPTER QUIZ 3. Student A says that employees have a right to know if materials that they are working with are hazardous. Student B says that all employees must be trained about hazardous materials. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 3. Student A says that employees have a right to know if materials that they are working with are hazardous. Student B says that all employees must be trained about hazardous materials. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 4. Student A says that any technician working on an automotive A/C system must be certified. Student B says that all hazardous materials must be labeled. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 4. Student A says that any technician working on an automotive A/C system must be certified. Student B says that all hazardous materials must be labeled. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 5. To determine if a product or substance being used is hazardous, consult _________. a dictionary an MSDS EPA guidelines SAE standards

CHAPTER QUIZ 5. To determine if a product or substance being used is hazardous, consult _________. a dictionary an MSDS EPA guidelines SAE standards

CHAPTER QUIZ 6. Student A says that right-to-know laws state that employees have the right to know when they are working with hazardous materials. Student B says the right-to-know laws state that the employer has the responsibility to train employees about the hazardous wastes they will encounter in their workplace. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 6. Student A says that right-to-know laws state that employees have the right to know when they are working with hazardous materials. Student B says the right-to-know laws state that the employer has the responsibility to train employees about the hazardous wastes they will encounter in their workplace. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 7. Student A says that hazardous waste is material that the shop no longer needs that can pose a danger to people and the environment. Student B says that material safety data sheets (MSDSs) must be provided to all employees. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 7. Student A says that hazardous waste is material that the shop no longer needs that can pose a danger to people and the environment. Student B says that material safety data sheets (MSDSs) must be provided to all employees. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 8. Student A says that exposure to asbestos can cause serious health problems. Student B says that all brake and clutch lining materials should be treated as if they contain asbestos. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 8. Student A says that exposure to asbestos can cause serious health problems. Student B says that all brake and clutch lining materials should be treated as if they contain asbestos. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 9. Two students are discussing the disposal of used motor oil. Student A says that used motor oil should be recycled. Student B says that 1 gallon of used motor oil will make 1 million gallons of freshwater undrinkable. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 9. Two students are discussing the disposal of used motor oil. Student A says that used motor oil should be recycled. Student B says that 1 gallon of used motor oil will make 1 million gallons of freshwater undrinkable. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 10. Solvents are often used in automotive repair. Student A says that physical contact with solvents should be avoided. Student B says that all solvents should be used in open, well-ventilated areas. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 10. Solvents are often used in automotive repair. Student A says that physical contact with solvents should be avoided. Student B says that all solvents should be used in open, well-ventilated areas. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 11. Student A says that used coolant can be recycled or, with a permit, disposed of by pouring it down a drain. Student B says that new or used antifreeze can cause death if it is swallowed. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 11. Student A says that used coolant can be recycled or, with a permit, disposed of by pouring it down a drain. Student B says that new or used antifreeze can cause death if it is swallowed. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 12. Student A says that the lead in batteries is toxic and battery acid is corrosive. Student B says that used batteries must be recycled. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 12. Student A says that the lead in batteries is toxic and battery acid is corrosive. Student B says that used batteries must be recycled. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 13. Student A says gasoline vapors are very dangerous. Student B says that gasoline should never be used to clean parts. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 13. Student A says gasoline vapors are very dangerous. Student B says that gasoline should never be used to clean parts. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 14. Air bags should be handled with caution. Student A says that air-bag systems should always be disarmed when working near them. Student B says that air bags should never be exposed to extreme heat or fire. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 14. Air bags should be handled with caution. Student A says that air-bag systems should always be disarmed when working near them. Student B says that air bags should never be exposed to extreme heat or fire. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 15. Two students are discussing used tire disposal. Student A says that recycled tires can be added to asphalt for roads. Student B says that used tires are a fire hazard. Who is correct? Student A Student B Both A and B Neither A nor B

CHAPTER QUIZ 15. Two students are discussing used tire disposal. Student A says that recycled tires can be added to asphalt for roads. Student B says that used tires are a fire hazard. Who is correct? Student A Student B Both A and B Neither A nor B