AIR CAR 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

INTRODUCTION Air Car- Powered by Air Engine. Having Emission Free Piston Engine using Compressed Air as Fuel. Gasoline- Main source of Fuel, Very Expensive and Impractical (Environmental Standpoint), Non- Renewable resource, it will eventually run out. One possible alternative is the air-powered car. Air Powered Cars runs on Compressed Air instead of Gasoline. Powered by two cylinder compressed engine. 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

VEHICLE PARTS COMPRESSED AIR TANK Are Localized Underneath the Vehicle. This Compressed Air Storage System is Safe to Risk of Explosion. Hold 90 cubic meters of air, compressed to 300 bars. Are the same tanks used to carry the liquid gas used by buses for public transport. Are Designed and Officially approved to carry an Explosive Product: Methane gas. Tanks are Not Made of Metals, Rather they are made Of Carbon Fibers. So if Tanks Rupture, They would not Explode, Rather They Would Crack 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

THE BODY Car Body- Built with Fiber and Injected Foam. Two main advantages: Cost and Weight. Sheet Steel-Low Cost than Fiber. Fiber is safer. It doesn’t cut like steel. Easier to Repair, glue, doesn’t rust. 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

THE AIR FILTER Air- Compressed by On Board Compressor Or Service Stations Equipped with High-Pressure Compressor. Before compression, Air must be Filtered to get rid of any Impurities. Carbon Filters are used to Eliminate dirt, dust, humidity and abundant abrasive particles. System eliminates and reduces existing Pollution. The Exhaust pipe on the Air-Powered Cars produces clean air which is cold on exit (between 15o and 0o) and harmless to human life. The air that comes out of the car is cleaner than the Air that went in. 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

THE CHASSIS Chassis- Highly resistant, Light, Aluminium Rods glued together. Aluminium rods Enables to build More Shock-Resistant Chassis than Regular Chassis. The rods are Glued in the Same way as Aircraft. Allowing quick assembly. More secure join than Welding. This System helps to reduce Manufacture Time. 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

TECHNOLOGY DESCREPTION Piston 1- Takes in Air, Compresses at 300 psi & 200 *F in Compression Chamber During 1st Cycle of Engine. Piston Pauses. Small Amount Of Air is released in Expansion Chamber. It Creates Low Pressure of 140 psi, Low Temperature, Low volume. A High Speed Shutter Connects the Compression & Expansion Chamber. Sudden Pressure & Temperature Difference in the two Chamber creates Pressure Wave in Expansion Chamber, Thus Producing Work that drives the piston to Power the Engine. 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

BASIC PRINCIPLE Uses an Innovative System to Control the Movement of the Second-Generation Pistons and one single crankshaft. The pistons work in two stages and one intermediate stage of compression and expansion. Engine has two functions: To compress ambient air. To make successive expansions thereby approaching isothermic expansion. 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com CAT’s Engine Detailed view

WORKING Compressed air- Stored in Fiber or Glass Fiber Tanks at a Pressure of 4500 psi. Fed through Air Injector to the Engine & flows into a Small chamber, where Expansion occurs. Air Pushes the Piston down & moves the Crankshaft, which gives Power. Car can run on Traditional Fuel in Combination with Air. The change of energy source is controlled electronically. Car Speeds- <60kph,it runs on air. >60kph it runs on a fuel such as gasoline, diesel or natural gas. Tank can be refilled at the nearest Air Pump. Car motors require a small amount of oil (0.8 litres) that has to be changed just every 50,000km. 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

ARTICULATED CON-ROD The Con-Rod System- Allows the Piston to be held at Top Dead Centre for 70% of the cycle. This way, enough time is given to create the pressure in the cylinder. The torque is also better so the force exerted on the crankshaft is less substantial than in a classic system. 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

GEAR BOX MOTO-ALTERNATOR Gear Changes are Automatic, Powered by an Electronic system. A computer which controls speed of the car is effectively changing the gears. MOTO-ALTERNATOR The Moto-alternator connects the engine to the gearbox. It has many functions: Supports the vehicle’s motor to allow the Tanks to be refilled. As an alternator to produce Brake Power. Starts the Vehicle and Provides Extra Power when necessary. 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

DISTRIBUTION SYSTEM Engine uses a Simple Electromagnetic Distribution System which controls the flow of Air into the Engine. 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

COMPARISION WITH COMPETITION COMPARISION CHART 2000 NISSAN ALTRA EV 2003 TOYOTA RAV4 EV 2003 MDI CITY C.A.T. Fuel type Electric Compressed Air Mpg avg. [1] 123 104 198 Annual fuel cost [2] $331.00 $391.00 $220.00 Annual green house gas emissions [3] 3.5 4.1 1.2 Range 129 126 120-190 Top speed 75 mph 78 mph 68 mph Engine characteristics 62 kW AC Induction 50 kW DC 18.3 kW CCE Recharge time 5 h 6.75 h [4] 3 min or 4 h [5] Price $50,999 $42,000 $15000-$20,000 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

LEGEND: 1. MPG represents Number of Miles that can be travelled using equivalent Amount of Electrical Energy Compared with a gal of Gasoline. 2. Based on 45% Highway Driving, 55%City driving,15000 miles per year and following fuel prices: Electricity: $0.08 per kWh ($2.71 per gal of gasoline equivalent) 3.Green house gas emissions expressed in CO2 equivalents. 4.Based on tests conducted. 5.Three minutes through air station or 4 hour, if connected to conventional washer & dryer plug(220V). 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

MODELS A) FAMILY A Spacious Car with Seats which can face different directions. Its Design is based on the Needs of a Typical family. Specifications: Airbag, Air conditioning, 6 seats. Dimensions:3.84m,1.72m,1.75m. Weight:750 kg. Maximum speed:110 km/h, Mileage:200 - 300 km. Max load: 500 Kg. Recharge time: 4 hours (Mains connector) Recharge Time: 3 minutes (Air station) 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com On Board Computer

Specifications: Airbag, air conditioning,2 seats B) VAN Designed for daily use in industrial, urban or rural environments, whose primary drivers would be tradesmen, farmers and delivery drivers. Specifications: Airbag, air conditioning,2 seats 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com Steering Wheel

Specifications: Airbag, air conditioning, 6 seats C) TAXI Inspired by the London Taxi, with numerous ergonomic and comfort advantages for the passenger as well as for the driver. Specifications: Airbag, air conditioning, 6 seats 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com Steering Wheel

Specifications: Airbag, air conditioning, 2 seats D) PICK-UP The “Pleasure" car: designed for excursions, outdoor sports or water sports. Also suitable for tradesmen and small businesses. Specifications: Airbag, air conditioning, 2 seats 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

Specifications: Airbag, air conditioning, 3 seats E) MINI CAT The smallest and most Innovative: Three seats, Minimal dimensions with the Boot of a saloon. A great challenge for such a small car which runs on compressed air. The Mini Cat is the city car of the future. Specifications: Airbag, air conditioning, 3 seats Dimensions:2.65m, 1.62m, 1.64m. Weight:750 kg, Maximum speed:110 km/h. Mileage: 200 - 300 km Maximum load: 270 Kg. Recharging time:  4 hours (Mains connector) Recharging time:3 minutes (Air station). 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

ADVANTAGES Fast recharge time. Long storage lifetime Of Air. Potentially lower initial cost than battery electric vehicles when mass production takes place. A Pure Compressed Air Vehicle produces no pollution at the tailpipe. The compressed air engines also offer drivers the option of using fossil fuels or bio-fuels to heat the air as it enters the engine.   Air cars are lighter than conventional cars. 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

DISADVANTAGES When Compressor runs on Gasoline, it will create Pollution. One-to-two hour Waiting for the Car's built-in Air Compressor to Compress air could become a problem on cross-country trips. The distance that an Air Car can cover without refueling is crucial because very few filling stations will have compressed air pumps available.  123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

CONCLUSION Air powered cars is a Realization of latest technology in automobile field. It eliminates the use of Non-Renewable fuels. Prevents Pollution caused by Millions of Automobiles all over the world. This could be the future of automobiles and step to a Healthier Environment. 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com

THANK YOU 123seminarsonly.com email us for more reports 123seminarsonly@gmail.com