Scorpion DCP

Remote Access Dry-Coupled Crawler System Scorpion DCP Remote Access Dry-Coupled Crawler System

Non-encoded dry coupled crawler designed to be: Scorpion DCP Non-encoded dry coupled crawler designed to be: Cost effective Simple to set up and use Compatible with any UT set

Scorpion DCP Adds remote access thickness measurement capability to existing UT equipment

Unique Dry Coupled Wheel Probe Scorpion DCP Unique Dry Coupled Wheel Probe No liquid couplant required 2.5mm near surface resolution

Scorpion DCP A 5mhz, twin crystal transducer is mounted in the centre of the wheel probe axle

A pair of 12mm thick Ro-Cee rubber tyres fit over the Probe axle Scorpion DCP A pair of 12mm thick Ro-Cee rubber tyres fit over the Probe axle A cork washer prevents cross-talk between each side of the transducer

Unique Properties of Ro-Cee rubber : Scorpion DCP Unique Properties of Ro-Cee rubber : High wear resistance Attenuation very close to water Similar impedance to Perspex An effective alternative to liquid or gel Ultrasonic couplant

Scorpion DCP A neodymium magnet mounted in front of the wheel probe maintains adequate probe pressure

No wasteful water-feed required Scorpion DCP No wasteful water-feed required Able to climb higher than a water fed crawler (no water to carry) Supplied with 50M Umbilical

Scorpion DCP Simple to setup Easy to use

Compatible with most UT set Scorpion DCP Compatible with most UT set UT set connects to Control Module via standard BNC connectors

Neodymium belly magnets & wheel magnets Scorpion DCP Neodymium belly magnets & wheel magnets 13.6KG pull-off force

Powered by 12V battery Pack Scorpion DCP Powered by 12V battery Pack Ruggedized for site use Provides 8 hours continuous operation Audible low voltage alarm

Scorpion DCP Four independently controlled drive-wheels provide full steering control

Minimal training required No water required Scorpion DCP Cost effective Simple to set up and use Minimal training required No water required Able to climb higher than water fed alternatives (50M)

www.silverwinguk.com Silverwing NOT OPERATOR DEPENDENT TECHNOLOGY DRIVEN