Www.dot.state.pa.us Michigan DOT Concrete Bus Tour August 13, 20008 Bill Miller, PE, Chief, Quality Assurance Division, West Bureau of Construction and.

Slides:

Advertisements

Similar presentations

Going Green 2010 Northeast Association of State Transportation Officials Annual Meeting (NASTO) June 13, 2010 Wilmington, DE Jim Pappas DelDOT Materials.

Advertisements

A Look to the Future By: Pat Hughes, Dave Holt, and Ron Bumann.

Project Description and Needs Lincoln Way Widening Addition of a center-turn lane and safety improvements to the grade and horizontal alignment. Needs.

Moving transportation into the future Strategic Highway Research Program.

CONCRETE 2010 The 10 th Annual Concrete Conference for the Maryland Transportation Industry New Challenges and New Opportunities.

Using CFB Ash As A Substitute For Portland Cement In Full Depth Reclamation Presented By Steve Dixon, Civil & Environmental Consultants, Inc. Jim Panaro,

Rigid Pavement Concrete. Transverse Cracking Rigid Pavement Transverse Cracking Causes:  Slab longer than 15’ Slab Curl Curing.

Concrete Specification and Roadway Standard Revisions Bill Miller, PE Bureau of Construction and Materials Mark Burkhead, PE Bureau.

USE OF POLYURETHANE GROUT FOR CONCRETE PAVEMENT SLAB STABILIZATION Indiana County District 10-0 Lessons Learned 1.

From… Maintenance Technical Advisory Guide (MTAG) Chapter 1 Introduction.

Alternate Bidding: The West Virginia Experience 2011Virginia Concrete Conference March 3, 2011 Richmond, VA Bob Long Executive Director ACPA Mid-Atlantic.

Concrete Overlay (Whitetopping) in MD

2013 Concrete Pavement Construction at MnROAD Tom Burnham, P.E. Minnesota Department of Transportation TRB AFD40 Monthly Seminar September 12 th, 2013.

European Asphalt Pavement Warranties Scan September 14-28, 2002.

Public Works Greg Chock Operations Manager Harlan Hanson Road & Bridge Engineer

District 8-0 Winter Schools /23/2012.

1 Resurfacing and Curb Ramps. 2 FHWA’s Americans with Disabilities Act Program / Section 504 of the Rehabilitation Act of 1973 The primary purpose of.

Sect. 12A-2 – Accessible SW Requirements ADA Clarifications: – When are curb ramps required? – What constitutes an alteration? – Does the scope of resurfacing.

PRESENTATION TO 34 TH ANNUAL AIRPORTS CONFERENCE 3/02/11 By: Casimir J. Bognacki, PE, FACI Chief of Materials Engineering.

PPTG Thin Overlays Task Group (TOADS) Team Overlay Asphalt Debaters Presented by Basem Muallem (CT) - Tony Limas (Industry) April 19, 2005.

From… Maintenance Technical Advisory Guide (MTAG) Chapter 6 Dowel Bar Retrofit.

Tranlation: EASL’s Average Daily Traffic Time or Traffic Pavement Condition Index Pavement Performance Pavement Condition High Performance Intersections.

Pavement Preservation Update By Shakir Shatnawi Chief, Office of Pavement Preservation PPTG Caltrans Co-Chair Gary Hildebrand and Casey Holloway PPTG Industry.

Calibration and Application of HDM-4 for the WSDOT Highway System Jianhua Li Steve Muench Joe Mahoney Department of Civil and Environmental Engineering.

Concrete Paving: Opportunities for Virginia Robert R. Long, Jr. Executive Director American Concrete Pavement Association Mid-Atlantic Chapter October.

A Urban Highway Infrastructure: Design For Long, Long Life Michael I. Darter, Ph.D, PE Principle Engineer, ARA, Inc. Director, Pavement Research Institute,

PUBLIC WORKS OPERATIONS: TRANSPORTATION Steve Hansen, PE Director of Public Works – Liberty, MO APWA PW Institute April 8, 2014.

Alternate Bidding in Missouri Transportation Estimators Association Annual Conference November 2-4, 2005 – Daytona Beach, FL Interstate 44 … South-Central.

Pavement Preservation and the Role of Bituminous Surface Treatments—A Washington State View Rocky Mountain Asphalt Conference February 20,

Concrete Pavement Quality Improvement Committee Update Joseph S. Robinson, P.E. Chief, Quality Assurance Division Bureau of Construction.

MnDOT Road Research Update Maureen Jensen January 17, 2014.

HIGWAY ENGINEERING Session 05 Subject: S0012 / Introduction to Civil Engineering Year: 2007.

Highway Maintenance & Rehabilitation

From… Maintenance Technical Advisory Guide (MTAG) Chapter 7 Isolated Partial Depth Concrete Repair.

Street and Local Roads Inspection and Acceptance of Alternative Pavements.

Ultra Thin Continuously Reinforced Concrete - Modelling &Testing under APT Louw Kannemeyer (SANRAL) Bryan Perrie (C&CI) Pieter Strauss (Consultant) Louw.

Pavement Maintenance II

Presented to: 32 nd Annual Airport Conference – Hershey, PA By: Jeff Gagnon, P.E. Manager AJP-6312 Date: March 4, 2009 Federal Aviation Administration.

Extending Asphalt Pavement Life Using Thin Whitetopping Mustaque Hossain, Ph.D., P.E. Department of Civil Engineering Kansas State University.

Pavement Preservation Protecting the Investment and the Environment R. Gary Hicks CP2 Center, Chico, CA Prepared for CEAC 2014 Conference March 26-28,

AASHTO SCOP Linking Planning to Programming P2P Link Rural Transportation Summit January 16, 2014 ADOT Vision and Long-Range Plan Planning to Programming.

Roadway Preservation Intranet Page. Location: Intranet/Roadway-Preservation.aspx.

ILLINOIS ROUTE 23 (LaSalle St.) DOWNTOWN RE-ALIGNMENT December 2, 2008.

FHWA Highways For LIFE Technology Partnerships Program Intelligent Asphalt Compaction Analyzer October 01, 2007 – September 30, 2009 Haskell Lemon Construction.

Chapter 3 Framework for Treatment Selection From… Maintenance Technical Advisory Guide (MTAG)

ROADS AND BRIDGES (RESEARCH-DEVELOPMENT) Dr. László Gáspár research professor ERTRAC National Platforms Workshop 5 September 2008, Budapest ERTRAC National.

Early Performance of Concrete Pavement Overlays in Minnesota Tom Burnham, P.E. Minnesota Department of Transportation 15 th Annual TERRA Pavement Conference.

MICHIGAN EXPERIENCE WITH WARRANTY WORK. Warranty Program History Why Warranties ? Warranty Specifications Experience & Lessons Learned.

Transportation Engineering and Road Research Alliance Rory L. Rhinesmith, P.E Wisconsin DOT Mid Continent Transportation Research Symposium 08/15/2013.

PennDOT’s 2010 Program Rebecca S. Burns, P.E. Acting Director Bureau of Construction and Materials 11 th Annual Pennsylvania Concrete.

LTPP Lessons Learned: Delaware SPS-2 Wednesday April 9, 2014 SPS-2 Tech Day, Dover, DE Gabe Cimini Project Manager, LTPP North Atlantic Regional Support.

HBP Warranties – The Cost Benefit Evaluation Begins By: Jay Goldbaum, P.E. Colorado Department of Transportation Pavement Management and Design Program.

Michigan Department of Transportation Pavement Demonstration Program Rep. Rick Olson’s 2012 Best Practices Conference on Road and Bridge Maintenance Curtis.

Seismic Methods Used To Check Strength of Concrete Runway Reconstruction Dean Rue, P.E. CH2M HILL 2010 FAA Airport Technology Transfer Conference Atlantic.

National Cooperative Highway Research Program (NCHRP)

What is a Resource? Any physical or virtual entity of limited availability A new or reserve supply that can be drawn upon when needed Something that one.

Using Reflective Crack Interlayer-

Pavement Preservation Program Emily McGraw, PE February 23 and 24, 2015 – NCDOT & CAPA Workshop.

To The For The. CITY OF GLENDALE, CA Community Meeting, January 9, 2016 Ocean View Blvd. Looking South Intersection Verdugo Road and Ocean View Blvd.

CITY OF GLENDALE, CA APRIL 2, 2015 BRAND BLVD, GARDENA AVE & ADJACENT STREETS – SEWER AND STREET IMPROVEMENTS, AND TYBURN SEWER TRUNK LINE AT RAILROAD.

ORDINANCE # Authorizing $372,760 for traffic signal interconnect at 47 th Street and Emanuel Cleaver II Boulevard Start of project End of project.

Jerry L. Larson IRMCA Indiana LTAP Basics of a Good Road

Design and Rehabilitation Strategies for Sustainable Concrete Pavements H. Thomas Yu Federal Highway Administration Office of Pavement Technology.

European Asphalt Pavement Warranties Scan

Implementation of pavement preservation treatments

Pavement Preservation

MnDOT Concrete Engineer

Prime Factors for Successful Preservation Treatments

FHWA’s Advanced Concrete Pavement Technology Program

ACEC Designer Training

Presentation transcript:

Michigan DOT Concrete Bus Tour August 13, Bill Miller, PE, Chief, Quality Assurance Division, West Bureau of Construction and Materials 10 th Annual Concrete Conference January 27, 2009

10 th Annual Concrete Conference

10 th Annual Concrete Conference Two Part Format Presentation and discussion of projects (1 ½ hours) Bus Tour of project sites (6 ½ hours)

10 th Annual Concrete Conference Demonstration Projects (Performance Update) Dowel bar retrofit alignment verification study Deicer study effects on PCC (MichiganTech Transportation Institute)

Presentation and Discussion Dowel bar retrofit alignment verification study Device developed in Germany Non-destructive quick method to check dowel bar alignments FHWA owns three MIT-Scan II devices can be borrowed through the Concrete Pavement Technology Program (CPTP)

Deicer study of effects Determine Long Term Exposure to Magnesium Chloride, Calcium Chloride & Sodium Chloride Estimate Potential Reduction in Service Life on PCC Pavement Pavement Performance was Significant Better with Ground Blast Furnace slag or Fly Ash in the Mix Sealants Improved Performance, Need to be Reapplied Every 3- 5 Years

Pavement Tour 4”-6” White- topping –intersections, collector streets and ramps

Pavement Tour

Observations White-topping projects 4-6” deep, construction very similar to PennDOT. Intersection reconstruction is almost entirely white topping and the connecting roadway. Rutting issue was eliminated. Anticipating 20 year pavement life tour projects in-place 4-10 years with no performance issues.

Pavements Tour 6.5” Concrete Overlays 4 lanes –high truck traffic

Pavement Tour

Observations Concrete overlays 6.5” depth unbonded, 1 ½” asphalt over existing concrete Minimal spall & joint repairs, only areas with base failure Transverse joint alignment is not required Anticipating 25 year pavement life Michigan is experiencing very good performance.

Best Practices Warranty for materials and workmanship, all projects Alternate bidding – currently very limited bituminous bids Pavement committee reviews all design & construction changes

Results Significant Initiatives Alternate Bidding Procedure Warranty Specification Pavement Preservation –Overlays

THANK YOU