Diesel Hammers History Single Acting Double Acting.

Slides:

Advertisements

Similar presentations

Engine Operation Chapter 3

Advertisements

Engines and Motors.

Cessna Single Engine Aircraft Maintenance

2 Stroke cycle engines

Chapter 7 - Heat Science for X. Agenda Heat Engines External combustion engine Internal combustion engine Petrol engine Diesel engine Efficiency of heat.

Engine Choose a Number 23 End = Esc.

Copyright © PracticalStudent.com The Four Stroke Engine – Whole Engine.

LESSON TEN. AIR AND EXHAUST SYSTEMS AND TURBOCHARGERS.

Two Stroke The biggest diesel engine in operation, work on two stroke principle. It is called two stroke because it takes two strokes of piston to complete.

CHAPTER 3 INTERNAL COMBUSTION ENGINES

Diesel Engines TRF 210. History of Diesel Engines 1890 Dr Rudolf Diesel had a theory that any fuel could be ignited by the heat caused by high pressure.

Internal Combustion Engines – The Diesel

1 Start Four Stroke, Two Stroke Diesel, & Wankel Engine Theory and Operation.

Transportation engineer. Introduction The Internal Combustion (I.C.) engine is a heat engine that converts chemical energy (in the fuel) into mechanical.

Diesel Engines Transportation Mr. O’Rourke. History Invented in the 1890’s in Germany by Rudolf Diesel. Invented because of the inefficiency of steam.

Spark plug Inlet valve Exhaust valve CylinderPiston The four-stroke engine.

Exhaust valve Exhaust valves open inwards into the cylinder, so that the gas pressure in the cylinder will ensure positive closure and help in dislodging.

Diesel Automotive Engines

BASIC MECHANICAL ENGINEERING. INTERNAL COMBUSTION ENGINES.

Diesel Engine The only difference between diesel engine and a four-stroke gasoline engine is: No sparkplug on Diesel engine. Has a higher compression ratio.

Internal Combustion Engines – The Diesel References Required Principles of Naval Engineering – (pP ) Optional Introduction to Naval Engineering.

Piston Engine Operations

Introduction Diesel Engine.

Diesel Power Plant Mr.B.Ramesh, M.E.,(Ph.D) By

FUEL INJECTION SYSTEM OPERATION

8.2 Automobiles. What is a car engine? Physicists call it a “heat engine” The specific design is an “internal combustion engine”

Diesel Engines By: Douglas Aycock April 8, History Named after Dr. Rudolf Diesel Originally replaced the stationary steam engine –75% efficient.

The Diesel Cycle By: Ben Brady How It Works. The Creator Created by Rudolph Diesel Had a dream for a more efficient engine than the steam engine Developed.

Basic Engine Operation & Construction

Internal combustion engine

The Diesel Cycle By Marcus Low. What is the difference? The Diesel engine takes in JUST air. The compression ratio is higher, thus higher efficiency.

The Diesel Engine The Combustion Cycle The four-stroke combustion cycle of the diesel engine is composed of the intake stroke, compression stroke, power.

The 4-Stroke Engine Spark Plug InletValve Exhaust Valve CylinderPiston The 4-stroke Engine.

Supreme Power Engine Basics The four cycle engine.

© 2011 Pearson Education, Inc. All Rights Reserved Automotive Technology, Fifth Edition James Halderman GASOLINE DIRECT- INJECTION SYSTEMS 79.

Four Stroke Cycle In 1892 Rudolph Diesel invented the compression ignition engine named after him. The first engine was built at Augsburg Maschinenfabrik.

Cost Effective Driven Piles Air Hammer Diesel Hammer Hydraulic Hammer.

The piston descends from the top of the cylinder to the bottom of the cylinder, reducing the pressure inside the cylinder. A mixture of fuel and air,

INTERNAL COMBUSTION ENGINES. EXTERNAL VS INTERNAL  external- combustion engine  typically steamed powered  heated water would produce steam to increase.

Internal Combustion Engines Submitted by: Enrollment no: Divyesh Patel Bhavik prajapati Parth vagashiya Guided by:

MODREN INSTITUTE OF TECHNOLOGY & RESEARCH CENTRE VIPIN KUMAR YADAV.

Automotive Engine Performance, 3/e By James D. Halderman Copyright © 2010, 2007, 2003 Pearson Education, Inc., Upper Saddle River, NJ All rights.

Unit 61: Engineering Thermodynamics Lesson 12: Combustion Engines.

5 Principles of Engine Operation, Two- and Four-Stroke Engines.

IN THE NAME OF ALLAH THE MOST BENEFICIENT THE MOST MERCIFUL:

Automotive Technology

Small Engine Principles of Operation Test

Common Rail Direct Injection CRDI

Internal Combustion Engines

Unit 61: Engineering Thermodynamics

Figure 36.1 A gasoline direct-injection (GDI) system injects fuel under high pressure directly into the combustion chamber.

STARTING OF IC ENGINES.

Figure 24.1 A gasoline direct-injection (GDI) system injects fuel under high pressure directly into the combustion chamber.

Diesel engines mu.

Fuel in the common tube or “rail” is under a set amount of pressure which causes the fuel to be “atomized” or broken down to its smallest particles. This.

Gas Power Cycle - Internal Combustion Engine

Diesel Automotive Engines

THE OTTO CYCLE (engine)

Four Stroke Compression Ignition (CI) Engine

Introduction to Engine Parts, Operation and Function

Engine Design and Classification

The Otto Cycle By: Vijai Sookrah

1 4 STROKE DIESEL CYCLE Direct Injection INDUCTION 0 deg

Energy Conversion Engines take heat energy and convert it into mechanical energy. Motors take electrical energy and convert it into mechanical energy.

The four-stroke engine

Engine Choose a Number End = Esc 2 6.

Presentation transcript:

Diesel Hammers History Single Acting Double Acting

Nazi’s Invent Diesel Hammer

Single Acting

Diesel Hammers

Diesel Hammer Replaces Air Hammers Light Weight Better Fuel Economy Higher Energy Ease of Use Advantages:

A closer look: Upper cylinder Upper piston Exhaust port Oil pump Fuel pump Injector Lower piston

Strokes of Single acting diesel

Fuel Pump Operation

APE/Delmag Fuel Pump Note: To double stroke the fuel pump you must be on full throttle and then jerk the right hand rope after piston passes fuel pump lever on upper stroke.

Fuel Pump element

Wear Item that can change stroke and fuel setting. Know your dimensions. Pressure Piece

How to check dimensions

Fuel Pump & Injector

Fuel Pump Exploded View

Stop Valve Main Check Valve of pump Gets bent O-ring melts Always have a back up of this part

Stop Valve

Three Check Valves you need to know Return Valve Stop Valve Non return valve

Fuel Pump checks

Lube Pump

Trip

APE Variable Fuel Pump

Atomization Prior To Impact

Original Patent for High Pressure Injection

Operation cycle Ignition Exhaust

Operational Cycle Compression Injection of fuel

ICE & Berminghammer

Side by Side Comparison

ICE Delmag/APE