Gasoline Dispenser Hose Permeation Workshop November 13, 2003 Monitoring and Laboratory Division Air Resources Board California Environmental Protection.

Slides:

Advertisements

Similar presentations

1 EVALUATION OF EVAPORATIVE EMISSIONS FROM ONROAD MOTORCYCLES January 15, 2006.

Advertisements

Evaporative Emissions from Small Engines Harold Haskew July 2, 2003.

Off-Highway Recreational Vehicle Workshop 12/18/2012.

1 Proposed Evaporative Emission Standards for Boats Mike Samulski Office of Transportation and Air Quality International Boat Builders’ Exhibition & Conference.

Recent EPA Regulation Development Presented by Bill Luthans to the 56 th Meeting of the Joint Advisory Committee Meeting for the Improvement of Air Quality.

November 14, 2003 Aboveground Storage Tank Enhanced Vapor Recovery.

ARB’s Intent to Establish Evaporative Emission Standards for Pleasure Craft NMMA/ARB Meeting Feb. 7, 2006.

Small Engine Workshop Exhaust Emission Program Mobile Source Control Division November 13, 2002.

Spark-Ignition Marine Engine and Boat Regulations Staff Presentation Air Resources Board July 24, Air Resources Board California Environmental Protection.

Evaporative Emission Control for Gasoline Boat Fuel Systems Mike Samulski U.S. Environmental Protection Agency International Boatbuilders’ Exhibition &

CALIFORNIA AIR RESOURCES BOARD DIESEL EMISSIONS STANDARDS AL UPTON BUTTE COUNTY FLEET MANAGER  Four separate rules apply to Public Agencies  On-Road.

MICHELLE WILSON ARIZONA DEPARTMENT OF WEIGHTS AND MEASURES SEPTEMBER 17, 2013 Stage II Vapor Recovery Update.

Minnesota Air Quality and Attainment Status Frank Kohlasch Kari Palmer Statewide Travel Demand Coordinating Committee Meeting October 14, 2010.

California Air Resources Board Enhanced Vapor Recovery.

Unihose Dispenser Workshop June 16, 2004 Monitoring and Laboratory Division Air Resources Board California Environmental Protection Agency.

Mobile Source Control Division November 13, 2002 Planning and Technical Support Monitoring and Laboratory Division California Air Resources Board Proposed.

California Air Resources Board December 12, 2002 Enhanced Vapor Recovery Technology Review.

12/25/2009 Pleasure Craft Proposal Draft Pleasure Craft Evaporative Emissions Regulation and Standards.

Workshop on the Origin and Development of the Keeler Dunes Great Basin Unified Air Pollution Control District Governing Board Meeting March 7, 2013 Part.

2007 Grant Programs to Reduce Air Pollution Public Workshop Feather River Air Quality Management District August 10, 2007.

1 Evaluation Of Evaporative Emissions From Pleasure Craft June 27, 2007.

2006 Grants Programs to Reduce Air Pollution Public Workshop Feather River Air Quality Management District March 17, 2006.

1 Public Hearing to Consider Proposed Amendments to the Emission Inventory Criteria and Guidelines Regulation for the AB 2588 Air Toxics “Hot Spots” Program.

Vandenberg Air Force Base E-85 Fueling Facility California Air Resources Board E-85 Workshop Presented by Stu S. Webster Metcalf & Eddy 02 February 2006.

California Air Resources Board Workshop November 3, th Street, Room 202 1:30 - 3:30 p.m. Aboveground Storage Tank Enhanced Vapor Recovery.

Portable Fuel Container Public Workshop California Air Resources Board Monitoring and Laboratory Division October 20, 2004 Understanding Spillage.

Draft Statewide Strategies ARB Control Concepts for 8-hour Ozone and PM2.5 Plans Jeff Lindberg CA Air Resources Board October 17, 2006.

California Air Resources Board Status of the Portable Fuel Container Spillage Control Regulations.

How will we enforce AB32? It's tough to make predictions, especially about the future. Yogi Berra It's tough to make predictions, especially about the.

Proposed Amendments to Enhanced Vapor Recovery Regulations November 18, 2004 Monitoring and Laboratory Division Air Resources Board California Environmental.

Monitoring and Laboratory Division April 25, 2002 Planning and Technical Support Division Mobile Source Control Division California Air Resources Board.

Inventory Needs and Legal Requirements Martin Johnson Emission Inventory Workshop Air Resources Board March 13, 2006.

Workshops on Discussion Draft of Guidelines December 2014.

Enhanced Vapor Recovery Amendments Workshop September 9, 2002 Air Resources Board California Environmental Protection Agency.

OTC Attainment Planning Update SIP Steering Committee April 13, 2011.

Proposed Regulations for Portable Fuel Containers Refueling Spillage Control Project January 26, 1999 California Environmental Protection Agency Air Resources.

1 June 23, 2004 Sacramento Thermal Spraying ATCM Second Public Workshop.

Monitoring and Laboratory Division July 2, 2003 California Air Resources Board Small Off-Road Engine Workshop Evaporative Emission Program.

Cargo Tank Program Emissions and Regulation Development Public Workshop March 2, 2005 ARB, MLD 1st Floor Conference Room th Street Sacramento, CA.

1 May 4, 2004 Sacramento Thermal Spraying ATCM Public Workshop.

1 Small Off-Road Engines and Large Spark-Ignition Engines with Displacement Less Than or Equal to One Liter Workshop April 21, 2008.

1 SJVAPCD DRAFT SCHEDULES May 2, Hr OZONE ATTAINMENT DEMONSTRATION PLAN PM10 ATTAINMENT DEMONSTRATION PLAN.

1 Fuels Workshop California Environmental Protection Agency Air Resources Board May 2, 2005.

Evaporative Emission Standards for Boats

Massachusetts’ 4-Pollutant Power Plant Regulations Sharon Weber Massachusetts Department of Environmental Protection Air Innovations Conference - August.

MLD - Proposed TP Proposed Vapor Recovery Test Procedure TP DYNAMIC PRESSURE PERFORMANCE Public Workshop, June 20, 2001 CALIFORNIA AIR RESOURCES.

FINAL1 Inventory, Emissions, and Population July 2, 2003 AIR, Inc.

1 Mississippi Air Quality Update Mississippi Dept. of Environmental Quality Air Division August 5, 2011.

13/3/2010 Spark-Ignition Marine Engine Draft Proposal.

Mobile Source Control Division September 25, 2003 Monitoring and Laboratory Division Board Hearing California Air Resources Board Control Measure to Reduce.

Portable Fuel Container Spillage Control Project Monitoring and Laboratory Division June 28, 1999 California Environmental Protection Agency Air Resources.

1 Evaporative Emission Standards for Boats Office of Transportation and Air Quality IBEX Meeting October 2011.

Public Workshop Proposed RACT/BARCT Determination for Stationary Spark-Ignited Internal Combustion Engines August 29, 2000 California Environmental Protection.

1 Setting Evaporative Emission Standards for Off Highway Recreational Vehicles (OHRV) March 23, 2006.

California Air Resources Board Evaporative Emission Proposal John McKnight IBEX Miami Beach Convention Center October, 13, 2009.

Mobile Source Control Division July 2, 2003 Planning and Technical Support Division Public Workshop Monitoring and Laboratory Division California Air Resources.

Engineering Evaluation Unit Monitoring and Laboratory Division California Air Resources Board (916) ABOVE GROUND STORAGE TANK (AST) VAPOR RECOVERY.

PROPOSED AMENDMENTS TO THE STATEWIDE PORTABLE EQUIPMENT REGISTRATION PROGRAM California Environmental Protection Agency Air Resources Board June 22, 2006.

Refueling Spillage Control For Small Off-Road Engines Air Resources Board August 6, 1998 Dean Bloudoff.

Presented at the Fifth Annual California Unified Program Conference February 6, 2003 Enhanced Vapor Recovery Cindy Castronovo Air Resources Board Cal-EPA.

November 15, Clean Air Act Framework National Ambient Air Quality Standards (NAAQS) set public health goals Planning process considers science,

1 Draft Landfill Methane Control Measure California Air Resources Board April 22, 2008.

Implementation of National Ambient Air Quality Standards Bill Harnett NACAA Fall Meeting September 22, 2009.

Pat Bennett Engineering Evaluation Section Monitoring and Laboratory Division California Air Resources Board AST EVR WORKGROUP MEETING April 17, 2002.

 To discuss MassDEP’s draft revisions to the following regulations:  Stage II – 310 CMR 7.24(6)  Stage I – 310 CMR 7.24(3)  Definitions – 310 CMR.

AB 118 Air Quality Improvement Program (AQIP) Proposed 2011 Funding Plan Air Resources Board Meeting July 21, 2011 CALIFORNIA ENVIRONMENTAL PROTECTION.

1 Pat Bennett Engineering Evaluation Section Monitoring and Laboratory Division California Air Resources Board Aboveground Storage Tank Enhanced Vapor.

MPCA Citizens’ Board Meeting: United States Steel Corporation-Keetac Air Emissions Permit Owen Seltz Industrial Division September 13, 2011.

The Florida Energy and Climate Commission (FECC)

EVALUATION OF EVAPORATIVE AND EXHAUST EMISSIONS FROM OFF-HIGHWAY RECREATIONAL VEHICLES (OHRV) September 06, 2006.

Presentation transcript:

Gasoline Dispenser Hose Permeation Workshop November 13, 2003 Monitoring and Laboratory Division Air Resources Board California Environmental Protection Agency

2 Agenda Introductions Background for Regulating Hose Permeation Baseline Emission Estimate Suggested Standard Testing Considerations Cost-Effective Analysis Schedule

3

4 SIP Vapor Recovery Measures

5 Gasoline Dispenser Hoses

6 UL Standard for Safety for Hose and Hose Assemblies for Dispensing Flammable Liquids Six day, 3150 cycle/day flex test Refill hose every 24 hours Divide volume of fuel added over the six days by volume of the hose Allows 30% total loss

7 Hose Permeation Emissions Assume 12 hoses/station Assume gasoline permeation at levels allowed by UL 330 Estimate 3 tons/day statewide

8 SAE J1527 Marine Fuel Hoses Applicable to hoses on pleasurecraft 100 g/m2/day permeation limit up to 1.7 tons/day emission reductions statewide

9 Permeation Regulations Portable fuel containers (CA) –0.4 g/gal/day per TM 513 (SHED) Small off-road engine fuel tanks (CA) –2 g/m2/day per TP-901 Nonroad Large SI Engines and Recreational Engines (Marine and Land) fuel hoses (USEPA) –5 23 deg C per SAE J1527

10 Low Permeation Fuel Hose Technology Entire hose made with low permeation material Low permeation barrier layer(s)

11 Permeation Testing Test existing hoses to refine baseline emission estimate Test prototype hoses to set best achievable permeation limit Identify options for certification test

12 Testing Considerations Durability - aging and cycle tests Pre-Conditioning –fill hose with fuel and wait for saturation Type of fuel Hose configuration –single or co-axial Temperature –typical or worst-case? Cost of test

13 Cost for Low Permeation Hoses USEPA estimates incremental cost of $1.00/ft for engine fuel hoses For 12 foot coax hose => $24 Used $50 increase/hose for initial cost estimate Hoses today cost $100 - $200 (?)

14 Cost-Effectiveness Assume hose life of one year Assume cost increase of $50 per hose Total annual cost = $6,780,000 $6,780,000/yr 1 ton 1 yr 1.7 tons/day 2000 lb 365 days = $5.46/lb

15 hose perm Cost-effectiveness for ARB Major Regulations

16 Tentative Rulemaking Schedule Feb complete preliminary tests Mar post draft standard and TP Apr second workshop Jun finalize staff proposal Aug release staff proposal Sept Board hearing* * schedule may slip due to testing and/or other priorities, but expect Board hearing no later than December 2004

17 Proposed Implementation Schedule Dec 2004* - approved by Board Sept finalize rulemaking and begin certification Jan 2007* - required for new installations Jan required for all facilities * commitment dates in revised SIP Settlement Agreement (June 2003)

18 Contact Information Cindy Castronovo (916)