Spray Tanks Large Openings Strainer For Filling Agitation Devise

Slides:

Advertisements

Similar presentations

Cecil Tharp MSU Pesticide Education Program Pesticide Education Specialist Department of Animal and Range Montana State University.

Advertisements

“Spray Application Accuracy” Nozzle Selection. Why are you here???? Are you concerned with accuracy? n $$ go bye, bye n Changing rates (< an ounce/acre)

when calibrating the sprayer

Chemical Application and Safety Jeopardy N.C. Cooperative Extension Robert H. Pleasants, Wayne County.

Oil Heat Nozzles.

MSU Extension Pesticide Education Turfgrass Pest Management (Category 3A) Pesticide Application Chapter 4.

Nozzle Selection for Spraying Herbicides Spray Smart-February 2, 2006 Curtis Rainbolt, Ron Rice, Les Baucum, and Darrin Parmenter University of Florida/IFAS.

SPRAYER CALIBRATION Nov

Calibration. Tools Needed for Calibration  Stopwatch  Measuring tape  Calibrated liquid container  Scale  Calculator  Pressure gauge  Flow meter.

Operating, Calibrating, and Maintaining Spraying Systems Lesson 5.

Nozzles and Pumps. NOZZLE TYPE Flat fan Hollow cone Flood jet.

Drift Reduction And Nozzle Selection Drift Reduction And Nozzle Selection Jim Wilson South Dakota State University Jim Wilson South Dakota State University.

Calibration using the Test Strip Method (Long Hand) Cecil Tharp Pesticide Education Program Montana State University Extension.

Unit 7: Application Equipment & Calibration Chapter 12.

Private Applicator Re-certification Quiz II For Fun and Prizes.

For more information contact:

Cleaning Field Sprayers to Avoid Crop Injury Is it drift or is it a contaminated sprayer?

INAG 106 Pesticide Use & Safety Course

 Spotty Pest Control  Wasted chemicals  Off-target damage  Higher costs - $$$  Environmental impact  Water and Air Quality  Public more aware of.

Sprayer calibration Maury Craig, IR-4 Program Coordinator Extension Plant Sciences Dept. New Mexico State University.

SPRAYER ACCURACY July 2003.

Spray Tip Update. Nozzle Technology Nozzles designed to reduce drift Improved drop size control Emphasis on ‘Spray Quality’

when calibrating the sprayer

MSU Extension Chapter 6 Equipment & Calibration. MSU Extension Equipment Selection n Depends on… –target –type of application –pest to be controlled –pesticide.

Pesticide Application Equipment Page 78 General Manual

when calibrating the sprayer

1/128 Method Of Calibration Calibrating Hand Sprayers And High Pressure Hand Guns Because a gallon = 128 ounces and the area to be sprayed is 1/128 of.

Replacing Your Spray Nozzle Biological and Agricultural Engineering Robert E. Wolf Extension Specialist Application Technology.

New Application Technologies u Bobby Grisso 4 Biological Systems Engineering.

Equipment Methods The Basic Function of a Sprayer: Distribution & Metering Apply a dilute amount of herbicide (Rate) in a determined volume of water.

Crop Protection Equipment and Calibration

Insect Control Field Days Sponsored by the Kansas Fruit Growers Association.

Application Decisions for the New Millennium? Robert E. Wolf Extension Specialist Agrichemical Technology Biological and Agricultural Engineering Dept.

SPRAYER CALIBRATION Nov

Spray Droplet Size Standard S-572 Robert E. Wolf Extension Specialist Application Technology Biological and Agricultural Engineering.

Selecting Nozzles while Calibrating Your Field Sprayer Cecil Tharp Pesticide Education Program Montana State University Extension.

Equipment II Nozzles Nozzles Selection Low Drift Nozzles.

1 Turf and Ornamental Pest Control. 2 Application Equipment: Two basic types of application systems:  Liquid (sprayers)  Granular.

Turf and Ornamental Pest Control Robert E. Wolf BAE Dept. Kansas State University.

New Technology for the Application of Crop Protection Products Using Ground Application? Robert E. Wolf Extension Specialist Agrichemical Technology Biological.

Equipment, Calibration, and Tip Selection Considerations for the Application of Herbicides Robert E. Wolf Extension Specialist Application Technology Biological.

Calibration and Calculations Made Easy for Turfgrass Applicators Fred Fishel, UF/IFAS Dept. of Agronomy S. Priest, UF/IFAS.

Comparison of Drift for Four Drift-Reducing Flat-fan Nozzle Types Measured in a Wind Tunnel and Evaluated using DropletScan  Software Robert E. Wolf &

Calibration of Sugarcane Sprayers Curtis Rainbolt, Ron Rice, and Les Baucum University of Florida/IFAS.

SPRAY EQUIPMENT Basic Components and Operations. Purposes  Used to apply agricultural chemicals  Spray pressures range from near 0 to over 300 pounds.

Spray Spectrum of Spray Droplets Concerning Fungicide Control in Dense Canopy.

Variable Rate Nozzles By: Kyle Dollins. What Can VRT Be Used For?

Application Concerns for Control of Invasive Species ‘A focus on Equipment & Calibration’

Application Concerns for Pasture Management Robert E. Wolf Extension Specialist Application Technology Biological and Agricultural Engineering.

Kansas State University Biological and Agricultural Engineering Department Influence of Spray Droplet Size on Paraquat and Glyphosate Efficacy Robert Wolf.

Kansas State University Biological and Agricultural Engineering Department Spray Droplet Analysis of Air Induction/Venturi Nozzles Using WRK’s DropletScan.

Side roll / Wheel roll Sprinklers. Layout Consideration  Obstacles  Fences  Power lines  Out buildings  Ditches  Roads  Wind.

Robert E. Wolf Associate Professor - Extension Specialist Application Technology, Bio & Ag Engineering, Kansas State University Biological and Agricultural.

Application Equipment for ASR Bobby Grisso Biological Systems Engineering.

“Spray Application Accuracy” Nozzle Selection. Why are you here???? Points??? Are you concerned with accuracy?

Sprayers, Calibration, Nozzle Selection, Efficacy, & Drift Considerations for the No-Till Farmer Robert E. Wolf Extension Specialist Application Technology.

Nozzle Technology…… Nozzles designed to reduce drift

The Affect of Flat-fan Nozzle Angle on Aerial Spray Droplet Spectra Presented at ASAE/NAAA Technical Session 39 th Annual NAAA Convention Silver Legacy.

Cecil Tharp MSU Pesticide Education Program Pesticide Education Specialist Department of Animal and Range Montana State University.

Kansas State University Biological and Agricultural Engineering Department Comparison of Drift Potential for Venturi, Extended Range, and Turbo Flat-fan.

Pesticide Drift MSU Pesticide Education Program Michigan Groundwater Stewardship Program (MGSP) Note to presenter: It is highly recommended to use one.

Work Sheet Calibration is included at the end of this presentation.

PLANT PRODUCTION MACHINERY AND EQUIPMENT

Considerations for Selecting Turf Spray Tips Maximizing control while minimizing spray drift!

WELCOME! 2016 Southeastern Hay Convention Brian Mathis

Extension Specialist Application Technology

Application Strategies to Improve Crop Health

Presentation transcript:

Spray Tanks Large Openings Strainer For Filling Agitation Devise Large Drain Cutoff Valves Pump Outlets Resist Corrosion Stainless Steel Fiberglass Polyethylene

AGITATORS

Nozzle Elements Nozzle Type Size Of Orifice Operating Pressure Spray Nozzle Body Strainer Cap Tip Nozzle Type Size Of Orifice Operating Pressure Discharge Angle Spacing On Boom Distance To Target

Pattern Uniformity - Spray Table

Broadjet (Boomless) Nozzles Roadside Spraying 10 to 40 Foot Swath Multiple Nozzles On Sprayer Head Droplet Trajectory Can Avoid Roadside Objects Sensitive To Wind

Roadside Spray Boom

Flat-Fan Nozzles Most Common Nozzle For Broadcast Herbicide Spraying 15-30 (40) psi Spray Patterns Should Overlap 12-14º Rotation Off Boom Alinement

Hollow Cone Nozzles Provide Good Droplet Penetration of Canopy Orchard Insecticides Broadleaf Crops 40-80 psi Means Drift Can Be A Problem

Pressure Rinsing Containers Penetrate Container

Triple Rinsing Containers Fill Container 10% Full Close Cap, Shake, Rattle and Roll Empty Into Spray Tank Repeat 2 More Times