Dynamometer for Testing Frequency Inverter Performance Andres Calle Otero, Alexander Sawyer, Christian Ratliff Advanced Power Electronics and Electric.

Slides:

Advertisements

Similar presentations

PV String Monitoring Solution

Advertisements

Inputs: Digital and 4 configurable for Digital or 10 bit Analog Outputs:4 - 8 amp Relays or 700ma Transistors (1 PWM) 4 Line by 18 Character fully.

Dr. HABEEB HATTAB HABEEB Dr. HABEEB HATTAB HABEEB Office: BN-Block, Level-3, Room Ext. No.: 7292 UNITEN.

Integrated Thermoelectric Photovoltaic Renewable Energy System Luocheng Wang, Jonathan Weiss, Antony Xenophontos Advanced Power Electronics and Electric.

1 Hardy Process Solutions – New Product Introduction HI6600 Series – Modular Sensor System Hardy delivers productivity solutions to manufacturers and processors.

POWER ELECTRONICS Instructor: Eng.Moayed N. EL Mobaied The Islamic University of Gaza Faculty of Engineering Electrical Engineering Department بسم الله.

WATERLOO ELECTRICAL AND COMPUTER ENGINEERING 40s: Circuits 1 WATERLOO ELECTRICAL AND COMPUTER ENGINEERING 40s Circuits Department of Electrical and Computer.

Turbo PMAC Clipper One Board Control Solution Low Cost, 4 Axis controller with I/O and Ethernet A Turbo PC/104 with Acc-2P combined for a 30% cost reduction.

EUT 1040 Lecture 10: Programmable Logic Controllers.

Wind Turbine Simulation (Phase IV) SDMAY Advisor: Dr. Venkataramana Ajjarapu.

Momentum Measurement Card Project supervised by: Mony Orbach Project performed by: Hadas Preminger, Uri Niv.

Gwynneth Davidoff, Kendall Pletcher, Mary Schmidt, Amy Whitcombe.

Characterization Presentation Spring 2006 Implementation of generic interface To electronic components via USB2 Connection Supervisor Daniel Alkalay System.

Craig Chan & Mike Abidoye

Aloha Proof Module Design Cabled Observatory Presentation School of Ocean and Earth Science and Technology February 2006.

Molly, Gwyn, Sam, and Eric.  We had assumed that components should have a rated current no more than mA above the requirement.  Fred says that.

Copyright © 2014 Rockwell Automation, Inc. All Rights Reserved. PUBLIC PUBLIC CO900G L04 - Basic PLC Programming with Micro800 ® Controllers.

2 Way FM Car Starter Dan Owens April 12, 2005 Instructor: Dr. Pao-Lo Liu Department of Electrical Engineering University at Buffalo Course Requirement.

CR1000s are only one part of a data acquisition system. To get good data, suitable sensors and a reliable data retrieval method are required. A failure.

Phase IV Presentation Group 7 Thomas Kudej Marko Sutovic Timothy Smith.

P07301 Summary Data Acquisition Module. Team Members.

2.5 High-Speed Discrete Control System

PROGRAMMABLE LOGIC CONTROLLERS PLC’S

PWM (Pulse Width Modulation)

PLC Fundamentals Module 2: Hardware and Terminology.

Wind Turbine Simulation (Phase IV) SDMAY Advisor: Dr. Venkataramana Ajjarapu.

MEASUREMENTS and CONTROL LAB

Advisor: Venkataramana Ajjarapu May Project Team Elsammani AhmedHassan Burawi Brandon JanssenKenneth Thelen.

Brief Overview of Hot Wire Anemometers GE 330: Mechatronics Paul Kawka.

Alternative Energy Class Room Automation Control System Lighting and Temperature Control By: Al Woodward EET-2011.

Engineer Training UV Electrical Cabinet (16 and above) TJ8300 / TJ8500 UV Electrical Cabinet (Machines 16 and above)

The Technion Israel institute of technology Electrical Engineering Dept. HSDS lab ECU project Part A final presentation By: Ehab Shakour & Gaby Shakour.

Signal Conditioning & I/O By: YH Goh Technical Evangelist RLC AP.

© The McGraw-Hill Companies, Inc McGraw-Hill 1 PRINCIPLES AND APPLICATIONS OF ELECTRICAL ENGINEERING THIRD EDITION G I O R G I O R I Z Z O N I 15.

Automated Data Acquisition for an Infrared Spectrometer Lauren Foster 1, Obadiah Kegege 2, and Alan Mantooth 2,3 1 Manhattan College, Bronx, NY, 2 Arkansas.

Unitronics 2009.

Senior Design Fall 2014 ECE Department and Center for Clean Energy Engineering Emily Simonelli Lindsay Sullivan Taniya Singh United Illuminating in Orange,

Regal Beloit Proprietary & Confidential What do I get? The X13 motor is a permanent magnet, three phase,brushless DC motor. A single phase drive is attached.

A new class in PC Data Acquisition Delphin Technology AG Felix Ottofuelling V5.0.

LDA Large Display for Analog Inputs. Agenda What is the LDA? Easy programming About the input Setpoint control Communication Other features Packaging.

1 Engineering Design - A general approach. 2 Outline Form a group Proposal (Presentation and 1 st Mandatory Meeting) Milestone A (Demo A and 2 nd Mandatory.

ADAM-4000 Modbus I/O Market Focus Mark Lin eAutomation Div. PSM Industrial Automation Group

Application Story Of ISaGRAF Embedded Controller Battery DAS 480 batteries, some power & security equipment of a telecom company 40 Ch. (10 pcs. I-87013)

Incoming Power Grid Monitor TEAM #3: JAMES MCCORMICK, ZHIHOUG QIAN, JACOB JEBB, VICTOR EZENWOKO, ALEX LANGE FACILITATOR: DR. ASLAM SPONSOR: GREAT LAKES.

William Weeks Electrical Engineering Team Leader Hardware USB Host Research and Documentation Jesse Killough Electrical Engineering USB Host MP3 Decoder.

Prepared by: Engr. Qurban Ali Memon 11ES (SEC- 1 & 2)

Senior Design Fall 2014 ECE Department and Center for Clean Energy Engineering Emily Simonelli Lindsay Sullivan Taniya Singh United Illuminating in Orange,

Induction Motor Emulation for Variable Frequency Drive Testing Geoffrey Roy, Amber Reinwald, Matthew Geary Abstract Prototype Testing and Results The focus.

Required and Elective Courses in Power Area. Required Power Courses u ECE 320/321 Energy Systems I/Energy Systems I lab: Covers single-phase AC measurements,

Introduction to ECE530 Analog Electronics What is it? Outline Why?

Dynamometer for Testing Frequency Inverter Performance Andres Calle Otero, Alexander Sawyer, Christian Ratliff Team 1603 Sponsored by Lenze Advanced Power.

Dynamometer for Testing Frequency Inverter Performance Andres Calle Otero, Alexander Sawyer, Christian Ratliff Advanced Power Electronics and Electric.

Dynamometer for Testing Frequency Inverter Performance Andres Calle Otero, Alexander Sawyer, Christian Ratliff Advanced Power Electronics and Electric.

ECE 101 Exploring Electrical Engineering Chapter 7 Data Acquisition Herbert G. Mayer, PSU Status 11/30/2015 Derived with permission from PSU Prof. Phillip.

Dynamometer for Testing Frequency Inverter Performance Andres Calle Otero, Alexander Sawyer, Christian Ratliff Advanced Power Electronics and Electric.

CONTROL SYSTEMS and INSTRUMENTATION Laboratory Department of Electrical Engineering Computer, Control and Elelectronic Engineering Sub-Study Program Head:

Lesson 1 PLC BASICS. PLC Definition  Programmable Logic Controllers are industrial computers that control machine and other applications.  PLC have.

Inverter Digital Electronics Project Institute of Physics University of Sindh Jamshoro.

Pre-requisite for 20+ ECE Courses

Current Status of IPM-Linac Control System

ProtoDUNE SP – Slow control temperature readout setup test

LDA Large Display for Analog Inputs

LEVEL CONTROL USING ULTRASONIC

Measures to Improve Power Quality in Distribution System

Analog to Digital Data Conversion

ECE Department and Center for Clean Energy Engineering

AMPLITUDE AND HARMONIC CONTROL

XW9048(Xantrex inverters)

Presentation transcript:

Dynamometer for Testing Frequency Inverter Performance Andres Calle Otero, Alexander Sawyer, Christian Ratliff Advanced Power Electronics and Electric Drives Lab (APEDL) ECE Department and Center for Clean Energy Engineering ITE 11/30/ /9/2014 Copyright © 2014 – Advanced Power Electronics & Electric Drives Lab (APEDL)

LabView 2

Current Sensors +15V, 0V, and -15V: Rated 480V How do we sample this using the PLC? 3

Project Management RACI Chart 4

Project Management Risk Cube 5

Project Management Gantt Chart 6

PLC 7 Requirements IN 5AI 2DI OUT 2AO(preferred) 8DO(minimum) OUT Scale Digital 0-24V Analog 0-10V

PLC P300 8 Model Information PLC integrated with HMI EtherCAt, LAN,CAN and USB capabilities No D/A Doesn’t seem feasible

PLC Information from James 9 Model Options FC5A-C24R2 ( VAC PLC w/ 14 Digital In/10 Relay out). This PLC supports 4 expansion modules (Analog expansion, Digital, etc) FC5A-C24R2D (same PLC as above but operates at 24VDC) FC5A-D16RK1 (24VDC 8 digital in/8 relay out, will need digital and analog expansion, supports 15 expansion modules) FC4A-HPC3 (RS-485 module needed on both PLCs for MODBUS). As to your question about the 24VDC on the analog, I got the following answer from my boss “ 4-20mA is the most popular with 0-10VDC being the second most popular. The 24VDC may be the voltage that goes over their 4-20mA current signal. The voltage is constant and may be 24VDC, it’s the current that changes in a 4-20mA signal.”

Final Presentation Outline Plan Project Statement ❑ Introduce Problem ❑ Introduce solution Project Management ❑ RACI ❑ Risk Cube ❑ Gantt Research Options review ❑ Etc… Design What we accomplish before presentation Build/Test What we accomplish before presentation Report Accomplishments Future Work Issues ❑ Dyne/material delay ❑ Delayed design selection What we could have done better 10 What is expected?