1. So, I Failed My OBD Inspection! Now What? Or, What is GCAF going to do for ME? (my tag is due tomorrow!), Or I believe in clean air BUT I need to register my car. I/M Solutions Salt Lake 2014 1

2. Georgia OBD Inspection Visual Inspection for the CAT(manual) – we found missing cats that OBD did not flag! OBD II Evaluation Fuel Cap Pressure Check (up to 2) I/M Solutions Salt Lake 20142

3. DATA Ga Currently Tracks K.O.E.O. Bulb Check (manual entry) Monitor Status MIL Command Status: On – Store DTCs (5) RPM During Test E-VIN, Cal ID, CVN (Off) CO, HC, CO2, RPM – During RTSI Events I/M Solutions Salt Lake 20143

4. OBD Inspection Section Non-Communication With OBD – Replace Missing fuse (96 Toyota Trucks) – Replace burnt out Fuse/link – Reprogram ECU (Chrysler) Lifetime Ext Warranty – Replace ECU (very rare) K.O.E.O. MIL Bulb Check Fail – Remove Tape/Sticker Over Bulb – Replace Burnt Out Bulb – Repair wire/connection I/M Solutions Salt Lake 20144

5. How to FAIL PASS a Georgia OBD Inspection Replace your MISSING converter (visual) Get your vehicle’s OBD II System READY Address the DTCs causing the MIL to be ON Replace your MISSING/LEAKING fuel cap –May occur during inspection I/M Solutions Salt Lake 20145

6. Quick Quiz In a room there is a grandmother, two mothers, two daughters, and one granddaughter. How many females are in the room? I/M Solutions Salt Lake 20146 Does your house have a hot water heater? Can a person go 8 days without sleeping? If it takes 8 men 10 hours to build a wall, how long will it take 4 men? Name the days of the week that begin with “T”

7. Readiness ISSUE FAILURE How long ago was the OBD system reset? – Miles (Km) driven since repair/reset – Minutes engine running since reset – Warm-up cycles since repair/reset Engine Coolant Temperature? (180 0 /195 0 ) What is the status of the FUEL TANK? What type of fuel is being used? Status of KAM fuse/circuit? I/M Solutions Salt Lake 20147

8. Readiness ISSUE FAILURE (cont) Fuel System Status (closed/reason not closed) Ambient Input Air Temperature Reading Long Term Fuel Trim Short Term Fuel Trim I/M Solutions Salt Lake 20148

9. MIL On, DTCs IN Memory How long has the MIL been ON? –Miles(Km) since MIL Command –Time since MIL Illuminated –Trips/Drive Cycles I/M Solutions Salt Lake 20149

10. What OBD Certification is the Vehicle? What is the OBD Standards to which the vehicle is programmed? OBD I, OBD II, EOBD, JOBD…. I/M Solutions Salt Lake 201410 What fuel is the OBD II system Expecting? Gasoline, Ethanol, Hybrid What is the Hybrid Battery Pack Remaining Life?

11. Odd Responses From OBD System How Many Monitors are reporting: 0, 3? I/M Solutions Salt Lake 201411 Engine RPM not varying? Capture RPM Multiple times Is the vehicle providing expected data? B1S1 O2 readings B1S2 O2 readings Is the Engine Temperature reading 35 0 when it is the middle of July?

12. Quick Quiz - Answers In a room there is a grandmother, two mothers, two daughters, and one granddaughter. How many females are in the room? I/M Solutions Salt Lake 2014 12 3 Does your house have a hot water heater? NO Can a person go 8 days without sleeping? NO TIME, ALREADY BUILT If it takes 8 men 10 hours to build a wall, how long will it take 4 men? YES Name the days of the week that begin with “T” TODAY and TOMORROW, IT HAS A COLD WATER HEATER, SLEEP AT NIGHT

13. Georgia House Bill 566 Allows for the driving of a vehicle by a “Service Professional” to perform a “Readiness Test Drive Sequence” as long as there is a work order in the vehicle less than 14 days old: will not be subject to penalties of an expired tag. Must be a legal repair business (insurance, licensed, workman’s comp, zoning) has OBD diagnostic equipment… I/M Solutions Salt Lake 201413

14. Why We Test Vehicle Emissions I/M Solutions Salt Lake 201414

15. Thank You Stephen Leydon Vehicle Emissions Testing Coordinator Georgia Department of Natural Resources (404) 675-6156 Steve.leydon@dnr.state.ga.us I/M Solutions Salt Lake 201415