1. Engineering Challenges in Algae Energy
Presented by Oilgae Team (

2. Engineering Challenges in Algae Energy
What am I here for?
To talk about
Alternative energy
Algae energy
Engineering challenges in algae energy

3. Alternative energy

4. Alternative Energy
Alternative energy refers to energy sources which are not based on the burning of fossil fuels or the splitting of atoms.
The renewed interest in this field of study comes from the undesirable effects of pollution both from burning fossil fuels and from nuclear waste byproducts.

5. Alternative energy Various forms of alternative energy ENERGY SOURCE
Renewable Energy
Non Renewable Energy
Wind
Solar
Hydro
Bio Based
Geothermal
Ocean
Hydrogen
Energy from Waste
Traditional
Alternative
Oil
Gas
Coal
Synfuel
Nuclear
Oil shale
Tar sands

6. Non renewable alternative energy
Nuclear
Synfuel
Oil shale
Tar sands

7. Nuclear energy
Nuclear energy is the energy that is trapped inside each atom.
Presently, nuclear energy provides for approximately 16% of the world's electricity.

8. Nuclear energy Cons Pros 1. Meltdowns 1. Little Pollution 2. Radiation
3. Waste Disposal
Pros
1. Little Pollution
2. Reliability
3. Safety

9. Synfuel
A gaseous, liquid, or solid fuel that does not occur naturally. Synthetic fuels can be made from coal, oil shale, or tar sands.

10. Synfuel
Pros-
Produce gasoline, diesel or kerosene directly without the need for additional steps
No need for new vehicles or convert engines to use a different fuel
No need for new distribution network
Less damaging to the environment
Cons-
Very expensive process It contain only the one-third the energy content of solid coal.

11. Oil shale
A sedimentary rock containing solid, combustible organic matter in a mineral matrix. The organic matter, often called kerogen, is largely insoluble in petroleum solvents, but decomposes to yield oil when heated.

12. Oil shale
Pros
Potential to produce a superior liquid-fuel product.
less complex process
low sulfur content and therefore less air pollution
Cons
Costs of fuel production from oil shale have not yet been fully evaluated.
Disposal of the used shale
Technology failures

13. Renewable alternative energy
Wind
Solar
Hydro
Geothermal
Hydrogen
Bio based

14. Solar energy
EPIA predicts solar will contribute 26% of total global energy needs by 2040.

15. Solar energy PROS- CONS- Saves money Potentially large areas required
Environmentally friendly
Independent/ semi-independent
Low/ no maintenance
CONS-
Potentially large areas required
Not many places in the world have enough constant and intense sunshine
Initial cost

16. Wind energy
“The global wind market to grow by over 155% from its current size to reach 240 GW of total installed capacity by the year 2012”
-Global Wind Energy Council
The electricity produced by wind energy will reach over 500TWh in 2012 from 200TWh in 2007 accounting for around 3% of global electricity production

17. Wind energy PROS- Clean Efficient Renewable CONS-
Wind might not blow when we need it
Hard to maintain
Too much space

18. Hydroenergy Cons – Pros –
Hydroenergy - energy that is taken from water and converted to electricity
Cons –
Change the local environment drastically
Many acres of land being flooded
Relocation of entire species that habitat the area
Pros –
No pollution
Most efficient energy sources possible
Sustainable power
Economical

19. Geothermal Energy
Geothermal Energy provides approximately 0.4% of the world global power generation, with a stable long term growth rate of 5%.

20. Geothermal Energy PROS- 1. Safe 2. Clean 3. Economical 4. Efficient
2. Clean
3. Economical
4. Efficient
5. One power plant can  produce a lot of steam by drilling more than one well
CONS-
1. May cause small after-shock earthquakes
2. Minor damage may take 1000 years to recover.

21. Hydrogen
Pros
Hydrogen is an extremely clean fuel, producing few emissions when combusted directly or in combination with hydrocarbon fuels.
When used in a fuel cell, the only byproducts are heat and water.
Hydrogen has the highest energy per weight rating (good fuel)
Cons
hydrogen is separated by a reforming process that uses natural gas and other fossil fuels.
The technology to produce, store, and transport hydrogen power at a reasonable cost is not yet in place and likely will not be for some time.

22. Alternative energy
Current market potential

23. Biofuels

24. First generation biofuels
Feedstock such as soybeans, palm, canola and rapeseed are considered first generation feedstock for biodiesel production, as they were the first crops to be tried for biodiesel production. Most first generation biodiesel feedstock could be used alternatively to make food for humans as well.

25. First generation biofuels
Pros:
Simple and well-known production methods
Familiar feedstocks
Scalable to production capacities
Easily blended with existing petroleum-derived fuels
Experience with commercial production and use in several countries
Cons:
Feedstocks compete directly with crops grown for food
Production by-products need markets
Low land-use efficiency
Modest net reductions in fossil fuel use and greenhouse gas emissions with current processing methods

26. Second generation biofuels
Non-food bio-feedstocks are considered as feedstock for second generation biodiesel. Either by using standard transesterification method, or by using technologies such as biomass to liquid (BTL), such feedstock could be converted to biodiesel.

27. Second generation biofuels
Pros
eliminates competition for food and feed
more efficient and more environmentally friendly
Less farmland is required mixture of crops can be used useful by-products are produced which can be used in other chemical processes or burned for heat and power.
Cons
same downfall as the first generation fuels but without as great of an eco imprint.

28. Third generation biofuels
Algae are considered to belong to the third generation of biodiesel feedstock.

29. Third generation biofuels
Pros
superior yields
not directly affecting the human food chain
grown in places that are not suitable for agriculture
enhanced efficiencies or reduction in cost
Cons
The problem of course is in developing technologies that will enable this kind of bioo fuel to be more cost effective to make.

30. Algae energy

31. History of energy from algae
The U.S. Department of energy’s Aquatic Species Programme, for example did over a decade of research (between 1978 and 1996), and found that algae were only economically viable as a biofuel at oil prices of more than $60 a barrel.
Since 2002, there have been a number of commercial and research efforts in the algae energy field, and the activities have further accelerated starting While most of the efforts in the first few years focused on biodiesel as the end-product, recently a number of efforts have recently been initiated to explore the viability of using algae as feedstock for other energy products.

32. Why is the field of algae energy interesting?
Micro-algae are the fastest growing photosynthesizing organisms. They can complete an entire growing cycle every few days.
Under optimum growing conditions micro-algae are reported to produce up to 15,000 gallons of oil/acre/year.

33. Why is the field of algae energy interesting?
Grown under conditions which are unsuitable for conventional crop production.

34. Why is the field of algae energy interesting?
Capable of fixing CO2 in the atmosphere, thus facilitating the reduction of increasing atmospheric CO2 levels, which are now considered a global problem.
Algae biofuel is non-toxic, contains no sulfur, and is highly biodegradable.

35. Energy products from algae
Biodiesel
Ethanol
Hydrogen
Methane
Biomass – where algae biomass is directly used for combustion
Other hydrocarbon fuel variants, such as JP-8 fuel, gasoline, biobutanol etc.

36. Biodiesel from algae Cultivation of Microalgae species
Harvesting of Microalgae
Extraction of Oil from Microalgae
Transesterification
Biodiesel

37. Ethanol from algae
Fermentation
Algae Biomass
Ethanol

38. Hydrogen from algae Biomass Gasification Biogas Fermentation
Dark Fermentation
Steam Reformation H2

39. Methane from algae
Algal Biomass
Anaerobic digestion
Methane

40. Current status of fuel from algae
Around 50 companies are working in this industry
Around 45 universities are actively exploring the potential of algae
Still in research level
There is no commercialization yet

41. Engineering Challenges in Algae Energy

42. Engineering Challenges in Algae Energy
Various types of engineering challenges
Engineering challenges
Mechanical
Biological
Chemical

43. Engineering Challenges in Algae Energy
Biological
- Strain selection
The algal strains to be cultivated would be selected based on productivity, and harvest ability, resistance to contamination, tolerance of high oxygen levels and temperature extremes.

44. Engineering Challenges in Algae Energy
Biological
- Maximize Photosynthetic Efficiency

45. Engineering Challenges in Algae Energy
Biological
- Increase the rate at which the algae grow, in order to harvest quickly

46. Engineering Challenges in Algae Energy
Biological
- Increasing lipid production of algae further

47. Engineering Challenges in Algae Energy
Biological
Devising suitable yeast for ethanol fermentation

48. Engineering Challenges in Algae Energy
Chemical
Transesterication
Cost of chemical harvesting
Removal of toxic chemicals in waste water for algae cultivation
- Nutrients for algae

49. Engineering Challenges in Algae Energy
Transesterication
High FFA in algae oil could create transesterification problems .FFA’s create 3 major problems.
- More catalyst will need to be used leading to higher cost
- Soap (fatty acid salt) is formed, making washing the finished product more difficult.
- Water is formed which will retard the main reaction
- The FFA’s are not converted into fuel, reducing the yield
So It is essential to treat the High FFA oil prior to transesterifiation.

50. Engineering Challenges in Algae Energy
Challenges in each and every process:
Algae cultivation
Open/Raceway pond
Photobioreactor
Algae Harvesting
Drying of algae
Oil extraction
Fermentation
Gasification

51. Algae Cultivation – Open pond / Raceway pond

52. Engineering Challenges in Algae Energy
Algae Cultivation – Open pond/Raceway pond
Growing algae in open ponds can lead to mal-odour in the ponds. This problem is mainly a result of lack of oxygen.
Open ponds can get contaminated.
Control in aeration
Efficient and energy intensive mixing
Design and engineering of cost effective open pond culture systems
Loss of water due to evaporation
Too much sunlight can kill algae. So it is essential to control the amount of sunlight falling on the algae cultivation area
Light penetration and problem of shading

53. Algae Cultivation - Photobioreactor

54. Engineering Challenges in Algae Energy
Algae Cultivation - Photobioreactor
With respect to system design, the technical challenges include:
reducing capital and operating costs,
maintaining temperature and pH control,
Removal of oxygen from the growth system
assessing water requirements (source, recycle, chemistries and evaporation issues),
determining CO2 availability and delivery methods,
Algae cultivation systems need to cost-effectively and evenly distribute light within the algae culture.

55. Algae Harvesting

56. Engineering Challenges in Algae Energy
Harvesting
Harvesting algae is much more difficult and energy intensive
Cost of harvesting (where centrifuges or flocculants are used, the costs could be significant) Ability to determine the right time to extract oil from feedstock is critical. Current methods to determine these are expensive, time consuming and unreliable
Scaling up of harvesting systems

57. Drying of Algae

58. Engineering Challenges in Algae Energy
Drying
Methods of drying other than Solar are highly expensive
Solar drying cannot be applied always
Solar drying is a slow process
High energy requirement

59. Algal Oil Extraction

60. Engineering Challenges in Algae Energy
Oil Extraction -Challenges
Algae organisms are protected by a tough cell wall. That wall must be cracked - an energy-expensive process - to extract the oil. The challenge is to maximize oil yield by cracking as many of the algae cells as possible with the smallest amount of energy.

61. Fermentation of Algal Biomass

62. Engineering Challenges in Algae Energy
Fermentation
Low cost Fermenters
Devising Closed loop reactors for recirculation of CO2 produced
Automation of fermentation followed by distillation process

63. Gasification of Algal biomass

64. Engineering Challenges in Algae Energy
Gasification
Very high capital cost
EROEI – not clear

65. Conclusion “Algae energy has excellent potential as a source of alternative energy but there are significant engineering challenges to be overcome”

66. Thank you