1. Network Solutions
Rev J. 11/8/2018

2. Presentation Overview
Network Hardware Types
Network Protocols
Network Adapters
MCS-Magnum Communication
MicroMag Communication
Example Network Configurations

3. Network Hardware Types
Three network hardware types that are used in MCS products:
RS485
Ethernet
LonWorks (twisted pair)

4. RS485 Hardware One twisted pair (two conductors)
Shielded wire – wrapped foil with drain wire
Minimum AWG 20
Max baud rate: 115,000 bit/s
Multidrop – point to point
Max 30 MCS Controllers wired together
Total Network cable length < 4000’ (1219m)
Can be lengthened with a repeater
Supported Data Format
Start bit:
1 bit
Data bits:
8 bits
Parity:
None
Stop bits:

5. Ethernet Hardware Star topography 4 twisted pairs (8 conductors) CAT5E
Max baud rate: 10 Mbit/s
Max cable length < 328’ (100m)
Can be lengthened with a switch

6. LonWorks Hardware One twisted pair (two conductors) Shielded wire
Free topography
Minimum AWG 20
Total Network cable length < 3280’ (1000m)
Can be lengthened with a repeater

7. Network Protocols
Network protocols are formatting rules that specify how data is sent and received between devices.
Protocols are necessary for devices to interact with each other.
Protocols MCS controllers support:
Bacnet
Modbus
LonTalk
Johnson N2
MCS

8. Network Protocols
The MCS Controllers support the following network protocols:
Over Ethernet
Over
RS485
Over LonWorks

9. MCS Network Adaptors MCS uses different optional network adapters:
Hardware Adapters
MCS-Ethernet (Ethernet – RS485)
MCS-I/O (RS485)
Hardware & Protocol Adapters
MCS-BMS-Gateway (Bacnet MSTP, LonTalk, Johnson N2)
MCS-Bacnet-Router2 (Bacnet IP)

10. MCS-BMS-Gateway Converts Bacnet MSTP (RS485) to: LonTalk (LonWorks)
Johnson N2 (RS485)
Converts Bacnet IP (Ethernet) to:
Bacnet MSTP (RS485)
Only supports one MCS-Magnum or MicroMag
Can be powered from MCS Controller
RS485
Johnson N2
Bacnet MSTP Or
MCS-Magnum
Ethernet
Bacnet IP
MCS-BMS-Gateway
LonWorks
LonTalk
RS485
Johnson N2
MicroMag
RS485
Bacnet MSTP
MCS-BMS-Gateway Or
LonWorks
LonTalk

11. MCS-Bacnet-Router2
Converts Bacnet MSTP (RS485) to Bacnet IP (Ethernet)
Supports up to 30 MicroMags
Can be powered from MicroMag
Ethernet
Bacnet IP
MicroMag
RS485
Bacnet MSTP
MCS-Bacnet-Router2

12. MCS-Pocket Router-2
Kit Components
110# power cord
USB cable to MCS-POCKET ROUTER-2
The MCS-POCKET ROUTER-2 is the perfect travel companion for easy wireless internet
The MCS-POCKET ROUTER-2, 2.4GHz wireless technology allows 11n data transfer rates of up to 150Mbps
Powered by USB for extreme portability
The MCS-POCKET ROUTER-2 can be USB-powered to ensure convenient internet access anywhere
Easy Setup
MCS-POCKET ROUTER-2 ships with a different default SSID and encryption enabled by default.
Advanced Security Features
To provide the highest data security possible, the MCS-POCKET ROUTER-2 supports WEP, WPA, and WPA2 encryption.

13. MCS-WIRELESS-4G Broadband Router with Integrated Verizon 4G Modem
(Only for use in USA)
The MCS-WIRELESS-4G is built for your network
The router features a built-in high-speed Verizon 4G EVDO modem. Supplied with one year subscription to MCS Wireless Verizon Data Plan, 250MB per month.
The MCS-WIRELESS-4G is a powerful tool that is especially useful in locations where there is no readily available internet connection. Combined with the data plan, the MCS-WIRELESS-4G may be used to wirelessly connect to the MCS-MAGNUM wherever a cellular signal is found.
You will receive everything you need to setup communication with an MCS Controller.
NOTE: The MCS-WIRELESS-4G can be used to communicate with multiple MSC Controllers.
for more information.

14. MCS-Magnum Communication
The MCS-Magnum comes with two hardware communication ports:
RS485 Port
Ethernet Port

15. MCS-Magnum Communication
The MCS-MAGNUM-DOOR-NEMA4 Keypad has been sealed in its own frame using a new Gasket (BISCO HT-800 Medium Cellular Silicone). The RS485 port has been added to the back of the Keypad. Moving the communicating port to the back, adding the new gasket, provides the unit
with a NEMA4 rating. Operating Temperature -4°F to +158°F (-20°C to +70°C)
Keypad showing
New design,
adding RS-485 connection
New Gasket
Provides the unit with a NEMA4 rating
RS485 port on the MCS-Magnum

16. MCS –USB-RS485
The MCS-USB-RS485 is a USB to RS485 level serial cable that provides a fast simple way to connect your computer to MCS controllers, MCS-MAGNUM and MICROMAG.
The MCS-USB-RS485 cable contains a small internal electronic circuit board, utilizing the FT232R, which is encapsulated into the USB connector end of the cable. Each cable supports the FTDIChip-ID™ and is equipped with a unique USB serial number programmed into the FT232R.
MCS-USB-RS485
MCS-MAGNUM PC
(MCS-Connect)
MicroMag

17. MCS-Magnum RS485 Building Management System
Using the RS485, the MCS-Magnum can be connected to the BMS (Modbus RTU or MCS 485 protocols)
MCS-MAGNUMS
Building Management System .
RS485

18. Wiring Multiple MCS Controllers
Using the RS485, the network must be wired controller to controller
Star configurations not allowed
Up to 30 controllers can be wired together
Correct
Incorrect
MCS-MAGNUM
MicroMag .
MCS-MAGNUM

19. MCS-Magnum Ethernet
Using the Ethernet, the MCS-Magnum can be connected to:
BMS (Bacnet IP or Modbus IP)
MCS-Touchscreen (MCS-Connect)
PC (MCS-Connect)
Internet access through router (which allows connection via MCS-Connect from anywhere) Or
MCS-MAGNUM Or Or
Ethernet

20. MicroMag Communication
The MicroMag comes standard with two independent RS485 ports:
Ethernet access can be added with the MCS-Ethernet
RS485 Port

21. Building Management System
MicroMag RS485
The MicroMag RS485 port can be used to connect:
MCS-Touchscreen (MCS-Connect)
BMS (Bacnet MSTP or Modbus RTU or MCS 485)
Building Management System
MicroMag
RS485 . or
MCS-TouchScreen

22. MicroMag RS485 The MicroMag RS485 port can be used to connect:
MCS-Touchscreen (MCS-Connect)
BMS (Bacnet MSTP or Modbus RTU or MCS 485)
Internet Access using:
MCS-Ethernet
Ethernet
RS485
9pinM  25pinM
MicroMag
Internet Router
RS485
MCS-485-GATEWAY
MCS-ETHERNET

23. Standalone MCS-Magnum
Example Network #1
Standalone MCS-Magnum
MCS-Touchscreen
MCS-MAGNUM
Ethernet
Ethernet
MCS-Touchscreen

24. Example Network #2 Standalone MCS-Magnum MCS-Touchscreen
BMS (Johnson N2 or LonTalk or Bacnet MSTP)
Internet Access
MCS-MAGNUM
RS485 or LonWorks
Building Management System
MCS-BMS-Gateway
Internet Router
Ethernet
MCS-Touchscreen

25. Example Network #3 Multiple MCS-Magnum Enclosures Internet Access
BMS (Bacnet IP or Modbus IP)
Rooftop/Chiller #1
Rooftop/Chiller #2
Ethernet
Building Management System
Internet Router

26. Building Management System
Example Network #4
Standalone MicroMag
MCS-Touchscreen
BMS (Modbus RTU or Bacnet MS/TP)
RS485
MicroMag
MCS-Touchscren
RS485
Building Management System

27. Building Management System
Example Network #5
Multiple MicroMags
BMS (Bacnet MSTP or Modbus RTU or MCS 485)
MCS-Touchscreen
RS485
RS485
MCS-Touchscreen
MicroMag
RS485
Building Management System
RS485
RS485

28. Advanced Example Network
Multiple MCS-Magnum & Multiple MicroMag
MCS-Touchscreen
BMS (Bacnet IP)
MCS-Touchscreen
Building Management System
MicroMag’s
MCS-MAGNUM’S
MCS-ETHERNET-SWITCH
MCS-Bacnet-Router2

29. QUESTIONS ON NETWORK SOLUTIONS

30. For additional information please visit our website www. mcscontrols
For additional information please visit our website
Or call MCS at
5580 Enterprise Pkwy.
Fort Myers, FL 33905
Office:
Fax: