1. International Forum on Qulaity and Safety in Health Care
Prevention of Surgical Site Infection
Liau Kui Hin, FRCS

3. Mission Statement
To reduce surgical site infections for gastrointestinal and hernia operations in Department of Surgery by 50% over the period of 6 months.

4. Rationale For Preventing SSI
2nd most common type of adverse events occurring in hospitalized patients
increase :
- mortality
- readmission rate
- length of stay
- cost for patients
40 to 60 % of clean and clean-contaminated wound infections are preventable

5. DEFINITION OF SURGICAL SITE INFECTION
TYPE
DEFINITION OF SURGICAL SITE INFECTION
Superficial
Incisional SSI
Infection occurs within 30 days after the operation
and
Infection involves only skin or subcutaneous tissue of incision
and at least one of the following:
Purulent drainage, with or without laboratory confirmation, from the superficial incision.
Organisms isolated from an aseptically obtained culture or fluid or tissue from the superficial incision.
At least one of the following signs or symptoms of infection: pain or tenderness, localized swelling, redness, or heat and superficial incision is deliberately opened by surgeon, unless incision is culture-negative.
Diagnosis of superficial incisional SSI by the surgeon or attending physician
Deep
Infection occurs within 30 days after the operation if no implant is left in place or within 1 year if implant is in place and the infection appears to be related to the operation
Infection involves deep soft tissues (e.g. fascial and muscle layers) of the incision
Purulent drainage from the deep incision but not from the organ / space component of the surgical site.
A deep incision spontaneously dehisces or is deliberately opened by a surgeon when the patient has at least one of the following signs or symptoms: fever (>38oC), localized pain, or tenderness unless site is culture-negative.
An abscess or other evidence of infection involving the deep incision is found on direct examination, during reoperation, or by histopathologic or radiologic examination.
Diagnosis of a deep incisional SSI by a surgeon or attending physician.
Organ
/ Space SSI
Infection involves any part of the anatomy (e.g. organs or spaces), other than the incision, which was opened or manipulated during an operation
Purulent drainage from a drain that is placed through a stab wound into the organ / space.
Organisms isolated from an aseptically obtained culture of fluid or tissue in the organ / space.
An abscess or other evidence of infection involving the organ / space that is found on direct examination, during reoperation, or by histopathologic or radiologic examination.
Diagnosis of an organ / space SSI by a surgeon or attending physician.

6. CAUSE & EFFECT DIAGRAM Environment Staff Equipment Infection Patients
– Skill mix
– nurse
– Physiotherapy
– Other patients
– Aseptic technique
– Cross infection
– Attire
– JMO education
– OT-traffic/attire/A/C
– Post-op: recannulation
– HDU
– Pre-op: when,
where, showers
– SCD machine
– Drainage systems
(closed or open)
Infection
Sterilization –
Surgical technique –
Operating time –
R/O drains –
Urinary catheter –
Clipping –
Temp Monitoring –
Glucose Monitoring –
Hair Removal –
Prophylactic Antibiotics –
– Blood loss
– Drainage systems
– Storage of equipment
– Post-op haematoma
– Dressings (time & type)
– Epidural insertion
– JMO involvement
– Selection
– Expectations
– Compliance
– Confusion
– Pressure ulcer
– Nutritional status
Patients
Procedure

7. Pareto Chart

8. Bundle of Interventions
Preoperative Hair Removal
• Remove all razors
• Work with the purchasing department
• Use reminders (signs, posters)
• Educate patients not to self-shave
Post Operative Glucose Maintainence
• Implement a glucose control protocol
• Regular blood glucose levels check
• Assign responsibility and accountability
Appropriate Prophylactic Antibiotics
• Change drug stocks to only standard drugs and dosage
• Reassign dosing responsibilities
• Involve pharmacy and infection control staff
Post Operative Normothermia
• Use warmed forced-air blankets and IV fluids
• Increase the ambient temperature in the operating room
• Use warming blankets under patients on the operating table
• Use hats and booties on patients perioperatively

9. Flow Chart of Process
Patient selected – labeled “SSI Protocol” in OT Reservation System
Surgical Site Infection Proforma Form - attached (pink)
OT Attendants – Hair Removal
Anesthetists – Antibiotics
PACU – Glucose & Temperature Monitoring
ICU/ HIGH D/ GENERAL WARD – Glucose Monitoring
Day Surgery Ward– Glucose Monitoring
Surgical Site Infection Proforma Form - Collected
HOME
Patient selected – labeled “SSI Protocol” in OT Reservation System
Surgical Site Infection Proforma Form - attached (pink)
OT Attendants – Hair Removal
Anesthetists – Antibiotics
PACU – Glucose & Temperature Monitoring
ICU/ HIGH D/ GENERAL WARD – Glucose Monitoring
Day Surgery Ward– Glucose Monitoring
Surgical Site Infection Proforma Form - Collected
HOME

10. Run Chart
Discussion began
Start of CPIP
Average
Target
2005
2006

11. Outcomes Clinical Cost Clean Clean-contaminated 0.35% 1.90% 0.00%
Pre-implementation
0.35%
1.90%
Post-implementation
0.00%
0.40%
Percentage Improvement
100.00%
78.95%
OVERALL = 82% (> target of 50%)
Cost
WARD
SUBSIDY PROVIDED
COST SAVED
Private A 0%
$0.00 B1
15%
$335.90
Subsidized B2
35-40%
$373.40 C
80%
$603.40
* Based on 10 days of hospitalization with surgical site infection

12. Lessons Learned
Standardization of workflow enhances the delivery of quality care and patient safety
Each individual’s contribution has significant impact on patient safety.
Quality initiatives are often welcomed when the outcome has significant impact on our patient safety.
Patient safety is not no accident & not by accident.