1. use of Industrial Reclaimed water 30 Texas Administrative Code Chapter 210 - Subchapter E
2019 Environmental Trade Fair & Conference
Monica Vallin-Baez
Environmental Permit Specialist
(512)

2. What is INDUSTRIAL RECLAIMED WATER?
Non-domestic wastewater re-used for a beneficial purpose
Industrial reclaimed water – Any industrial wastewater which has been treated, if necessary, to quality suitable for land application for beneficial use. The purpose of this subchapter is to establish the applicable requirements for industrial reclaimed water use which may be used instead of potable water or raw water.

3. Why re-use industrial wastewater?
Conserves raw or potable water resources
These requirements are intended to allow the safe utilization of reclaimed water for conservation of surface water and groundwater, to ensure the protection of public health, to protect surface water and groundwater from contamination, and to help ensure an adequate supply of water resources for present and future needs.

4. AVENUES FOR RE-USE INDUSTRIAL WASTEWATER
210E - LEVEL I
210E - LEVEL II
OTHER (INDIVIDUAL PERMIT)
Individual Permits (TPDES or TLAP)

5. WHAT IS LEVEL I NO NOTIFICATION TO TCEQ
NO PERIODIC TESTING (except cooling tower blowdown)
NO APPLICATION
NO FEE
NO WRITTEN AUTHORIZATION FROM TCEQ (beyond the rule itself)
NO TLAP OR TPDES PERMIT
NO EXPIRATION DATE
Periodic testing is required for cooling tower blowdown, a threshold concentration of total dissolved solids of 2,000 mg/L.

6. LEVEL I CONDITIONS WASTEWATER LISTED IN 210.53(a)
WASTEWATER IS REUSED ONSITE
ALTERNATIVE METHOD TO REUSE LISTED IN (b)(1)
END USE LISTED IN (b)(2)
Examples of wastewater authorized in Level I: non-contact cooling water, water treatment filter backwash, water from routine washing of pavement conducted without the use of detergents or other chemicals and where spills or leaks of toxic or hazardous waste have not occurred.
Other industrial wastewater – With measured effluent concentrations at or below threshold levels listed in Table I of 201E and for all other priority pollutants in 40 CFR 122 Appendix D, Tables II and III, the threshold level is set at the minimum analytical level.
END USES: irrigation including landscape, pastures for milking animals, non-food crops; fire protection; dust suppression and soil compaction; maintenance of impoundments

7. WHAT IF I DON’T MEET LEVEL I
WASTREAM IS NOT LISTED IN (a)
RE-USE IS ONSITE AND OFFSITE
COMMINGLED WASTEWATER
POLLUTANT CONCENTRATION EXCEED TABLE I THESHOLDS
Commingled wastewater - Industrial wastewater that contains any amount of domestic wastewater.

8. Threshold levels (§ 210.53, Table 1)

9. LEVEL II TCEQ APPLICATION (FORM No. 20094) APPLICATION FEE ($100.00)
INDIVIDUAL WRITTEN AUTHORIZATION FROM TCEQ
EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
CONDUCT ANNUAL TESTING

10. The following wastes are not eligible for a re-use authorization under 210E
Wastewater containing:
Radioactive Materials
Dioxins or furans
Pesticides
Wastewater classified as, or which is, hazardous as defined by 40 Code of Federal Regulations (CFR) Part 261

11. Additional wastes not eligible for re-use under 210E
Septic tank, chemical toilet, grit or grease trap waste
Barge cleaning or air scrubber wastewater
Any wastewater eligible for coverage under:
Permit by rule (30 TAC Chapter 321), or
Evaporation Pond General permit.

12. Where are the requirements for re-use of industrial reclaimed water?
30 Texas Administrative Code Chapter 210, Subchapter E (210e)

13. AM I SUBJECT TO Other requirements in Chapter 210?
If the end use is irrigation – see Subchapter B
If any type of impoundment is used to store reclaimed water – see Subchapter B
If reuse is off-site – see Subchapters A & B
If any amount of domestic wastewater is commingled with the industrial reclaimed water – see Subchapters A, B, & C

14. What about Greywater?
Re-use of greywater is subject to the requirements of 30 TAC Chapter 210, Subchapter F

15. A 210E authorization is not needed for:
Internal recycling systems
Closed-loop systems
Use of industrial wastewater as makeup water within a facility

16. contacts monica Vallin-baez monica.baez@tceq.texas.gov
(512)
Sarah Johnson, Ph. D
(512)
Mailing address: Water Quality Division
TCEQ, MC-148
P.O. Box 13087
Austin, Texas
TCEQ Website: