Presentation is loading. Please wait.

Presentation is loading. Please wait.

Www.orcnext.be ORCNext – WP4 Development of supercritical technologies Huisseune Henk 1.

Published byCecily Horton Modified over 9 years ago

Similar presentations

Presentation on theme: "Www.orcnext.be ORCNext – WP4 Development of supercritical technologies Huisseune Henk 1."— Presentation transcript:

1 www.orcnext.be ORCNext – WP4 Development of supercritical technologies Huisseune Henk 1

2 www.orcnext.be Test facility 2 Experimental setup Feeding pump Pre-heater Test-section Cooler Pressure gauges Flow meter Temperature sensors

3 www.orcnext.be Test facility 3 Test section Working fluid: R125 or R134a Uniform cross section: circular tube Electrical uniform heat flux (DC or AC power supply) Thermocouples

4 www.orcnext.be Measurements 4 Variation of the heat transfer coefficient with bulk temperature for forced convection in a heated pipe for carbon dioxide of 78.5bar flowing upwards in a 1.0 diameter vertical pipe.

5 www.orcnext.be Measurements 5 Wall and bulk temperature as a function of the distance along a vertical heated 1.6 cm diameter pipe for water at 245 bar (1.11 pcrit). Heat transfer deterioration – Downward flow  no unusual behaviour – Upward flow  Deterioration Flow direction 138227Vertical upward 238237Vertical upward 340045Vertical upward 437552Vertical upward 540027Vertical downward 640036Vertical downward 739343Vertical downward 838150Vertical downward Upward flowDownward flow

6 www.orcnext.be General characteristics Heat transfer deterioration 6 Comparison upward, downward and horizontal flow (1) Horizontal pipe – upper surface (2) Horizontal pipe – lower surface (3) Vertical pipe – upward flow (4) Bulk fluid temperature

7 www.orcnext.be Determine influence of parameters 7

8 www.orcnext.be Poc supercritical HX Using the insights obtained from the experiments, a Poc HX wil be designed and tested. Results will be used as model vallidation. Type: Shell and tube or (spiral) tube-in-tube heat exchanger. Built in test setup at Kortrijk. 8

9 www.orcnext.be Goals and planning 01/01/2013 – 31/06/2013: Design test setup with EES 01/07/2013 – 31/12/2013: Building test setup From 01/01/2014: Perform measurements on test loop 31/06/2014 – 31/12/2014: Design a Poc supercritical HX for model validation 9

10 www.orcnext.be ORCNext – WP4 Development of supercritical technologies Huisseune Henk 10

Download ppt "Www.orcnext.be ORCNext – WP4 Development of supercritical technologies Huisseune Henk 1."

Similar presentations

HEAT TRANSFER Final Review # 1.

HEAT TRANSFER Final Review # 1.
Quiz – 2014.02.05 An organic liquid enters a 0.834-in. ID horizontal steel tube, 3.5 ft long, at a rate of 5000 lb/hr. You are given that the specific.

Quiz – An organic liquid enters a in. ID horizontal steel tube, 3.5 ft long, at a rate of 5000 lb/hr. You are given that the specific.
Www.orcnext.be ORCNext – WP4 Development of supercritical technologies Catternan Tom 1.

ORCNext – WP4 Development of supercritical technologies Catternan Tom 1.
Liquids and Gasses Matter that “Flows”

Liquids and Gasses Matter that “Flows”
Estimation of Convective Heat Transfer Coefficient

Estimation of Convective Heat Transfer Coefficient
Chapter 2: Overall Heat Transfer Coefficient

Chapter 2: Overall Heat Transfer Coefficient
Heat Exchangers: The Effectiveness – NTU Method

Heat Exchangers: The Effectiveness – NTU Method
A 10-m long steel wire (cross – section 1cm 2. Young's modulus 2 x 10 11 N/m 2 ) is subjected to a load of 25.000 N. How much will the wire stretch under.

A 10-m long steel wire (cross – section 1cm 2. Young's modulus 2 x N/m 2 ) is subjected to a load of N. How much will the wire stretch under.
Example 1:- An annular alloyed aluminum (k = 180 W/m . K ) fin of rectangular profile is attached to the outer surface of a circular tube having an outside.

Example 1:- An annular alloyed aluminum (k = 180 W/m . K ) fin of rectangular profile is attached to the outer surface of a circular tube having an outside.
1 Dept. of Energy Technology, Div. of Applied Thermodynamics and Refrigeration Tube diameter influence on heat exchanger performance and design. Single.

1 Dept. of Energy Technology, Div. of Applied Thermodynamics and Refrigeration Tube diameter influence on heat exchanger performance and design. Single.
Design of Systems with INTERNAL CONVECTION P M V Subbarao Associate Professor Mechanical Engineering Department IIT Delhi An Essential Part of Exchanging.

Design of Systems with INTERNAL CONVECTION P M V Subbarao Associate Professor Mechanical Engineering Department IIT Delhi An Essential Part of Exchanging.
CHE/ME 109 Heat Transfer in Electronics LECTURE 17 – INTERNAL FORCED CONVECTION FUNDAMENTALS.

CHE/ME 109 Heat Transfer in Electronics LECTURE 17 – INTERNAL FORCED CONVECTION FUNDAMENTALS.
Free Convection: Mass Transfer Chapter 9 Section 9.10.

Free Convection: Mass Transfer Chapter 9 Section 9.10.
Heat Exchangers with Cross Flow past Cylinders P M V Subbarao Professor Mechanical Engineering Department I I T Delhi Another Common Industrial Application!!!

Heat Exchangers with Cross Flow past Cylinders P M V Subbarao Professor Mechanical Engineering Department I I T Delhi Another Common Industrial Application!!!
Lesson 15 Heat Exchangers DESCRIBE the difference in the temperature profiles for counter-flow and parallel flow heat exchangers. DESCRIBE the differences.

Lesson 15 Heat Exchangers DESCRIBE the difference in the temperature profiles for counter-flow and parallel flow heat exchangers. DESCRIBE the differences.
Fluidized Bed Name : Salman Alfihed Instructor : Dr. M. Alahmed King saud university Chemical Engineering Department.

Fluidized Bed Name : Salman Alfihed Instructor : Dr. M. Alahmed King saud university Chemical Engineering Department.
Heat Exchanger Heat exchangers can be described as:

Heat Exchanger Heat exchangers can be described as:
Respiration I. Introduction Oxygen and Carbon Dioxide.

Respiration I. Introduction Oxygen and Carbon Dioxide.
Www.orcnext.be ORCNext – WP4 Development of supercritical technologies Tom Catternan Henk Huisseune 1.

ORCNext – WP4 Development of supercritical technologies Tom Catternan Henk Huisseune 1.
HEAT EXCHANGERS.

HEAT EXCHANGERS.

Similar presentations

Ads by Google