1. © Influence Of Branch Content, Comonomer Type, And Crosshead Speed On The Mechanical Properties Of Metallocene Linear Low-Density Polyethylenes Islam, A; Hussein, IA JOHN WILEY SONS INC, JOURNAL OF APPLIED POLYMER SCIENCE; pp: 5019-5033; Vol: 100 King Fahd University of Petroleum & Minerals http://www.kfupm.edu.sa Summary The effects of branch content (BC) and comonomer type on the mechanical properties of metallocene linear low-density polyethylene (m-LLDPEs) were studied by means of a stress-strain experiment at room temperature. A total of 16 samples with different BCs and comonomer types were used. In addition, the effect of crosshead speed on the mechanical properties of m-LLDPEs with different BCs was examined. The degree crystallinity (X-t) of these copolymers was determined by differential scanning calorimetry. In addition, Ziegler-Natta linear low-density polyethylenes (ZN- LLDPEs) were also studied for comparison purposes. The increase in BC of m- LLDPEs decreased X(t)and the modulus. However, the ZN-LLDPEs showed higher small-strain properties but lower ultimate properties than the m-LLDPEs with similar weight-average molecular weights and BCs. In comparison with low-BC resins, m- LLDPEs with high BCs exhibited a stronger strain hardening during the stress-strain experiments. Strain hardening was modeled by a modified Avrami equation, and the order of the mechanically induced crystal growth was in the range of 1-2, which suggested athermal nucleation. The crosshead speed was varied in the range 10-500 mm/min. For low-BC m-LLDPEs, there existed a narrow crosshead speed window within which the maxima in modulus and ultimate properties were observed. The location of the maxima were independent of BC. The effect of the crosshead speed on Copyright: King Fahd University of Petroleum & Minerals; http://www.kfupm.edu.sa

2. 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15. 16. 17. 19. 20. 21. 22. 23. 24. 25. 26. 27. 28. 29. 30. 31. 32. 33. 34. 35. 36. 37. 38. © the mechanical properties of the m-LLDPEs was a strong function of BC. However, highly branched m-LLDPE in this experiment showed a weak dependence on the crosshead speed. (c) 2006 Wiley Periodicals, Inc. References: ALAMO R, 1984, J PHYS CHEM-US, V88, P6587 ALAMO RG, 1993, MACROMOLECULES, V26, P5740 ANDREWS JM, 1970, J MATER SCI, V5, P411 AVRAMI M, 1939, J CHEM PHYS, V7, P1103 AVRAMI M, 1940, J CHEM PHYS, V8, P212 BENSASON S, 1996, J POLYM SCI POL PHYS, V34, P1301 BROOKS NW, 1997, J POLYM SCI POL PHYS, V35, P545 BROOKS NWJ, 1999, POLYMER, V40, P7367 DASARI A, 2002, MATER SCI TECH-LOND, V18, P1227, DOI 10.1179/026708302225005945 DASARI A, 2003, MAT SCI ENG A-STRUCT, V358, P356, DOI 10.1016/S0921-5093(03)00330-7 FLORY PJ, 1978, NATURE, V272, P226 FREID JR, 2003, POLYM SCI TECHNOLOGY, V2 GRAHAM JT, 1997, J POLYM SCI POL PHYS, V35, P213 HAMEED T, 2002, POLYMER, V43, P6911 HAMEED T, 2004, MACROMOL MATER ENG, V289, P198, DOI 18.10.1002/mame.200300173 HERRERO CR, 1994, POLYM J, V26, P786 HUSSEIN IA, 2004, POLYM INT, V53, P1327, DOI 10.1002/pi.1528 JEZIORNY A, 1978, POLYMER, V19, P1142 JORDENS K, 2000, POLYMER, V41, P7175 JUANA RD, 1996, POLYMER, V37, P3339 KALE L, 1995, J PLAST FILM SHEET, V12, P27 KENNEDY MA, 1994, MACROMOLECULES, V27, P5297 KONTOU E, 2002, EUR POLYM J, V38, P2477 LIU T, 1988, POLYMER, V29, P233 LUCAS JC, 1995, POLYM ENG SCI, V35, P1117 MANDELKERN L, 1985, POLYM J, V17, P337 MARK HF, 1986, ENCY POLYM SCI ENG, V6, P477 MILLER BG, 2002, ANTEC, P2415 MINICK J, 1995, J APPL POLYM SCI, V58, P1371 PEACOCK AJ, 1990, J POLYM SCI POL PHYS, V28, P1917 PEACOCK AJ, 2000, HDB POLYETHYLENE STR, P516 POPLI R, 1987, J POLYM SCI POL PHYS, V25, P441 SACRISTAN J, 1999, J THERM ANAL CALORIM, V58, P559 SEGUELA R, 1986, POLYMER, V27, P532 SEGUELA R, 1986, POLYMER, V27, P703 Copyright: King Fahd University of Petroleum & Minerals; http://www.kfupm.edu.sa

3. 39. 40. 41. 42. 43. 44. 45. 46. 47. 48. 49. 50. 51. © SEHANOBISH K, 1994, J APPL POLYM SCI, V51, P887 SHAN CLP, 2002, POLYMER, V43, P767 SIMANKE AG, 1999, J APPL POLYM SCI, V74, P1144 SUMITA M, 1977, J POLYM SCI POL PHYS, V15, P837 TANEM BS, 2001, POLYMER, V42, P5389 TERMONIA Y, 1988, MACROMOLECULES, V21, P3485 TOBIN MC, 1974, J POLYM SCI PP, V12, P399 USAMI T, 1986, MACROMOLECULES, V19, P2722 VANDERWAL A, 1998, POLYMER, V39, P5477 WARD IM, 2000, INTRO MECH PROPERTIE, P237 WUNDERLICH B, 1976, MACROMOLECULAR PHYSI, V2, P147 WUNDERLICH B, 1997, THERMAL CHARACTERIZA, V1, P252 XU XR, 2000, J APPL POLYM SCI, V77, P1709 For pre-prints please write to: ihussein@kfupm.edu.sa Copyright: King Fahd University of Petroleum & Minerals; http://www.kfupm.edu.sa